Southbend SSB-45 - Manual (Page 18)

R ADIANT S TEAKHOUSE B ROILER
A DJUSTMENT OF B ROILER B URNERS
The burners are adjusted at the factory. Adjustment may be required to achieve proper operation due to elevation
change or other variables. Remove the burner cover to adjust the air shutter on each burner venturi (shown in Figure
6 on the previous page) to achieve proper combustion and optimum burn.
A
DJUSTMENT OF
G
AS
P
RESSURE
R
EGULATOR
The pressure regulator is located at the rear right lower corner of the broiler. The regulator is preset for 6" W.C. for
natural gas, or 10" W.C. for propane gas. If adjustment is necessary, do the following:
1. Turn the broiler control knobs to OFF.
2. Attach a pressure-measuring device to the 1/8" NPT connector located on the main manifold (accessible by
removing the grease drawer).
3. Turn the broiler control knobs to HIGH. With the burners lit, check the manifold pressure. The pressure should be
6" W.C. (for natural gas) or 10" W.C. (for propane gas).
4. If necessary, adjust the pressure by unscrewing the top of the pressure regulator (use a screwdriver) to expose
the adjustment screw underneath. Rotating the adjustment screw clockwise increases the manifold pressure.
5. After the pressure has been adjusted, turn the broiler control knobs to OFF, and replace the top cap of the
pressure regulator. Disconnect the pressure-measuring device and replace the plug into the manifold.
P
ARTS
The following table describes the serviceable parts. For parts not listed, contact a Southbend Authorized Parts
Distributor or a Southbend Authorized Service Agency.
PARTS LIST NATURAL GAS Quantity
Part Number DESCRIPTION SSB-32 SSB-36 SSB-45
1006436 BURNER ORIFICE 2 2 3
1176008 BURNER VALVE 2 2 3
1184384 PILOT ADJUST 1 1 1
1167782 REGULATOR,PRESS,WC @ 6",NAT 1 1 1
1130399 BURNER, HI-GLOW 2 2 3
1130398 VENTURI ASSEMBLY, HI-GLOW 2 2 3
1-5371 CERAMIC TILE 20 20 30
1189600 KNOB 2 2 3
PARTS LIST PROPANE GAS Quantity
Part Number DESCRIPTION SSB-32 SSB-36 SSB-45
1006451 BURNER ORIFICE 2 2 3
1176009 BURNER VALVE 2 2 3
1184384 PILOT ADJUST 1 1 1
1167783 REGULATOR,PRESS,WC @10",PROP 1 1 1
1130399 BURNER, HI-GLOW 2 2 3
1130398 VENTURI ASSEMBLY, HI-GLOW 2 2 3
1-5371 CERAMIC TILE 20 20 30
1189600 KNOB 2 2 3
P AGE 18 OF 20 O WNER ’ S M ANUAL 1190950 (02/09)