American Bath Factory Double Supreme Carolina Shower - Manual

GLASS DOOR & PANEL INSTALLATION
14
!
CAUTION
Glass is tempered, very strong, and impact resistant, but its weakest point is impact on edges and corners.
Do not rest edges of glass on hard surfaces.
Tempered glass cannot be cut
diagram 1
clear washer
clear
spacer
clear washer
set screw
shower
inside
shower
outside
A - Handle Installation
1. Set the glass door in a position to enable the assembly of the handle. (diagram 1)
2. Loosen the set screws so you can separate the handles.
3. Unscrew the long bolt from the handle. Keep all rubber pieces attached to the bolt.
4. Remove the first set of flat, clear washers from the bolt.
5. Start with the top hole on the glass door. Place the long bolt through the hole in the door
(keeping the remaining rubber pieces on the bolt). On the other side of the glass place the flat
washers onto the threaded portion of the bolt. (diagram 1)
6. Take one side of the handle and screw the long bolt into the end. Just start the bolt until a few
threads catch. Keep loose. (diagram 1)
7. Put the second bolt through the lower hole. Place the flat washer onto the bolt. Screw the bolt
into the bottom of the handle. (diagram 1)
8. Align the handle on the door and carefully tighten the long bolts. Do not over tighten.
9. Place the opposite handle over the long bolts and tighten the set screws to secure the handle.
B - Hinge Installation
1. Locate the top hinge and remove the side plate by loosening the two screws. (diagram 2)
2. Place the hinge into the top cutout on the door so the screws will be facing into the shower
and install the side plate. Tighten the screws until the hinge is secure. Make sure the hinge is
centered in the cutout and that the screws are facing into the shower. (diagram 2)
3. Repeat these steps for the bottom hinge.
Be careful not to rest the edges of the door on hard
surfaces. Tempered glass is very strong and impact
resistant but its weakest point is impact on the edges.
!
hinge pin
side plate
Be careful not to rest the edges of the door on hard
surfaces. Tempered glass is very strong and impact
resistant but its weakest point is impact on the edges.
diagram 2
side plate
hinge pin
shower
inside
shower
outside
teflon slide washer
teflon slide washer
hinge pin bracket
bolt
screw
(3 places)
carolina
double