Wiring diagram - model xsg only (see figure c) – Bakers Pride XMG-24,-36,-48,-60,-72 Manual User Manual
Page 6
TROUBLESHOOTING CHART
Burners & pilots will
not turn on
Burners produce
excessive carbon
deposits
Pilot will not remain
lit.
Griddle doesn't
seem hot enough
Griddle surface too
hot
Burners won't turn
on (XSG only)
Main gas supply to range is not
turned on.
Incorrect gas type.
Incorrect gas supply pressure.
Incorrect orifices.
Primary air not adjusted properly.
Pilot flame adjusted incorrectly.
Draft condition.
Orifices may be dirty/clogged.
Low gas pressure.
Thermostat set too high.
Thermostat defective.
Unit unplugged.
No power to outlet.
Turn on main gas supply.
Supply correct type gas.
Call local gas supplier.
Call Bakers Pride authorized service
center.
Adjust air shutter.
Adjust pilot flame.
Remove draft.
When unit cools, check & clean orifices.
Increase gas pressure to 3.5" W.C. (Nat)
or 10" W.C. (L.P.)
Reduce thermostat setting.
Replace thermostat.
Plug unit in.
Replace fuse or reset circuit breaker.
PROBLEM PROBABLE CAUSE SOLUTION
6
1.
Burner ports must be thoroughly cleaned. Venturi must be free from grease and lint.
2.
All places where oil, grease or food can accumulate must be kept clean all the time.
3.
Pilot light must be kept clean and adjusted at the proper flame height to assure constant ignition and
to prevent fire flash-outs caused by delayed ignition.
4.
Appliance flue has to be kept clean and free of any obstruction to ensure unrestricted flow of
combustion products from the unit.
5.
Carelessness, abusive handling, or altering equipment can shorten the life of the equipment and
jeopardize the limited warranty offered by Baker's Pride.
If you have any questions concerning the installation, operation, maintenance or service of this
product please contact Bakers Pride’s Technical Service Department at (800) 431-2745 US &
Canada.
Figure “C”
5. WIRING DIAGRAM - MODEL XSG ONLY (See Figure C)
120VAC
Black
White
Green
Electrical Box
Control Panel
Solenoid
Valve
Coils
Thermostats
450°F
Power
Switch
Neon
Indicator
Lamps
C1
C2
C3
C4
C5
C6
T6
T5
T4
T3
T2
T1
N1
N2
N3
N4
N5
N6
72”
60”
48”
36”
24”