Bally Refrigerated Boxes BC Air, Electric, and Hot Gas Defrost Blast Coolers - Manual

SERIES/GENERATION
A = 1st GENERATION
BALLY
JUMBO BLAST COOLER
BC 160 S - ED - T3 A
CONTENTS
Nomenclature.........................................
60Hz Capacity Data.................................
60Hz Air Flow Data..................................
Correction Factors.................................
60Hz Fan Motor Electrical Data.............
60Hz Defrost Heater Electrical Data.....
Refrigerant Charge................................
Air Defrost Wiring Diagram...................
Hot Gas Defrost Wiring Diagram..........
Electric Defrost Wiring Diagram...........
Refrigerant Piping Schematics............
Dimensions - Air & Electric Defrost.....
Dimensions - 3 Pipe Defrost &
Reverse Cycle Defrost Models.............
Installation Instructions.........................
Electrical & Refrigeration
Compartments........................................
Service Parts List...................................
Project Information................................
NOMENCLATURE
PAGE
Cover
2
2
2
3
3
3
4
4
5
6
7
8, 9
10, 11
12, 13
14
Back
• Incoloy defrost heaters mounted in slots on both sides
of cooling coils on electric defrost models.
• 3 - Pipe or reverse cycle hot gas defrost system.
• Factory installed hot gas check valve.
• Factory installed fan delay and defrost termination
thermostats on gas and electric defrost models.
• Hinged side panels allow easy access for refrigeration
circuit and electrical compartment.
• Schrader fitting and external equalizer line.
• Rugged high efficiency steel bladed fans.
• Plug-in motors with moulded lead and connector.
• Unit is shipped upright for convenient handling and
quick installation.
• Corrosion resistant, easy to clean vinyl coated fan
guards.
• Electrical terminals with recessed connections for
dependable operation.
MODEL
(DOES NOT NECESSARILY
REFLECT CAPACITY)
OPTIONS
P = PRE ASSEMBLED REMOTE
S = STANDARD UNIT
DEFROST
ED = ELECTRIC DEFROST
H = 3 PIPE HOT GAS
R = REVERSE CYCLE HOT GAS
ELECTRICAL DESIGNATION
T3 = 208-230/3/60
T4 = 460/3/60
T5 = 575/3/60
5 to 15 Tons at 10 °F (5.5 °C) T.D.
34 °F (1 °C) and Higher (Air Defrost)
-40 °F (-40 °C) and Above
(Medium and Low Temp)
Electrical Power: 208-230/3/60, 460/3/60,
575/3/60
BC Air, Hot Gas and
Electric Defrost
Blast Coolers 60Hz
PRODUCT DATA &
INSTALLATION
1047266
Bulletin: B30-BC-PDI-11