Ace 73-100 User Manual
Read and save these instructions
Attention! The text in this document has been recognized automatically. To view the original document, you can use the "Original mode".
ACE INDUSTRIAL PRODUCTS
PORTABLE AIR CLEANER
MODEL 73-200
INSTRUCTION & MAINTENANCE MANUAL
CAUTION:
This device is powered by rotating electrical machineryM Careless or improper use nnay result in
personal injury Read the Safety Precautions and Warnings contained within prior to operating this machine
READ AND SAVE THESE INSTRUCTIONS.
SAFETY WARNINGS & CAUTIONS
FAILURE TO OBSERVE THE FOLLOWING
PRECAUTIONS COULD RESULT IN SERIOUS
INJURY, INCLUDING DEATH IN EXTREME
CASES. SAVE THESE INSTRUCTIONS
WARNING: (EXPLOSION HAZARD)
This unit contains universal motors, which spark
during normal operation Do not use in areas
contaminated by volatile or flammable materials as
these sparks may ignite the contaminates and cause
a dangerous explosion
WARNING: (HARMFUL FUMES)
The filters used in this unit will remove solid
particulate ONLY, and do not eliminate fumes and
gases that may be a health hazard. Failure to
observe the presence of such fumes could cause
serious illness or death
CAUTION: (SHOCK HAZARD)
To insure continued protection against shock
hazard, connect AC cord only to properly grounded
outlets. Replace defective cords immediately. Do
not expose to moisture or liquid as this could defeat
the electrical insulation thus causing electrical
shock.
CAUTION; (STRONG VACUUM)
Care must be taken to avoid persona! injury by not
allowing hose inlet to contact any body area such as
eyes, ears, mouth, etc.
CAUTION: (LIFTING)
Although this unit weighs less than 40 lbs with
filters, improper lifting or handling of this unit could
cause back injury. Follow the recommended
method for lifting.
.
CAUTION; (AIRFLOW BLOCKAGE)
Since exhaust air leaves the bottom of this unit
caution should be observed not to set unit down in
such a way as to block the exhaust.
MISCELLANEOUS CAUTIONS:
1. Use of any attachment not recommended or
sold by the air cleaner manufacturer may result
in risk of fire, electric shock, or injury to persons
2
To reduce the nsk of damage to the electric plug
or cord, disconnect by pulling plug rather than
cord when removing power from the air cleaner
3.
Make sure cord and hose are located so they
will not be stepped on, tripped over, or otherwise
subjected to damage or stress.
4.
An extension cord should not be used unless
absolutely necessary Use of improper
extension cord could result in risk of fire and
electric shock If extension cord must be used,
use only a grounded cord and follow these
recommendations
25 ft -#14 AWG.
50 ft - # 1 2 AWG.
100 ft - #10 AWG
5.
Do not disassemble the air cleaner Take it to a
qualified serviceman when service or repair is
required. Incorrect reassembly may result tn risk
of electric shock or fire.
6.
To reduce the risk of electric shock or bodily
injury, unplug the air cleaner from outlet before
attempting any maintenance or cleaning
Turning off the power switch will not eliminate
this risk.