Sealey VS0287 - Manual


WARNING! Ensure all Health and Safety, local authority, and general workshop practice regulations are strictly
adhered to when using tools.
 DO NOT use tools if damaged or worn.

Maintain the tools in good and clean condition for best and safest performance.
 Ensure all threads are clean and well lubricated.
 Ensure that a vehicle which is jacked up is adequately supported with axle stands, ramps, etc. as appropriate.
 Wear suitable clothing to avoid snagging. DO NOT wear jewellery. Tie back long hair.
 Wear approved eye protection. A full range of personal safety equipment is available from your Sealey dealer.

Account for all tools and parts being used and do not leave them in or on the vehicle.
 Store all parts in the case provided when not in use, store case in a safe, dry and child-proof location.
 IMPORTANT: Always refer to the vehicle manufacturer’s service instructions, or proprietary manual, to establish
the correct procedure and data. These instructions for use are provided as a guide only.

WARNING! The warnings, cautions and instructions discussed in this document cannot cover all
possible conditions and situations that may occur. It must be understood that common sense and
caution are factors which cannot be built into this product, but must be applied by the operator.
INSTRUCTIONS FOR:
BRAKE PISTON WIND-BACK
TOOl KIT - 52 pc
MODEL NO:
VS0287
1. SAFETY INSTRUCTIONS
Original Language Version VS0287 Issue: 1 - 08/11/12
Thank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used according to these instructions and properly
maintained, give you years of trouble free performance.
IMPORTANT: PlEASE READ THESE INSTRUCTIONS CAREFUllY. NOTE THE SAFE OPERATIONAl REQUIREMENTS, WARNINGS AND CAUTIONS.
USE THE PRODUCT CORRECTlY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAIlURE TO DO SO MAY CAUSE DAMAGE
AND/OR PERSONAl INJURY AND WIll INVAlIDATE THE WARRANTY. PlEASE KEEP INSTRUCTIONS SAFE FOR FUTURE USE.
© Jack Sealey Ltd
● Alfa Romeo
● Audi
● BMW
● Citroen
● Fiat
● Ford
● Honda
● Jaguar
● Lancia
● Lincoln
● Mazda
● Mini
● Mitsubishi
● Nissan
● Peugeot
● Proton
● Renault
● Rover
● Saab
● Seat
● Subaru
● Toyota
● Vauxhall/Opel
● Volvo
● VW
3. APPlICATIONS
● Model No: VS0287
● Comprehensive master set of adaptors to suit a wide range of vehicle applications.
● Suitable for push-back and wind-back brake pistons.
● Includes left and right-handed thrust bolt assemblies.
● Left-handed thrust bolt required for: Citroen, Ford and Renault applications.
● Precision made adaptor plates with thrust bolt assembly and reaction plate.
● Kit helps prevent damage to pistons and seals.
2. INTRODUCTION