HONDA IGX440 - Manual (Page 7)

ENGLISH
STANDARD TYPES
LOW PROFILE TYPES
MAINTENANCE SCHEDULE
Recommended Fuel
REFUELING (STANDARD TYPES)
REFUELING (LOW PROFILE TYPES)
25 mm
(1 inch)
MAXIMUM
FUEL LEVEL FUEL TANK TOP
7
Service more frequently when used in dusty areas.
Follow the equipment manufacturers recommendation for
refueling.
Pump octane rating 86 or higher
Research octane rating 91 or higher
Pump octane rating 86 or higher
Unleaded gasoline
U.S.
Except U.S.
This engine is certified to operate on unleaded gasoline with a
pump octane rating of 86 or higher (a research octane rating of 91
or higher).
Refuel in a well-ventilated area with the engine stopped. If the
engine has been running, allow it to cool first. Never refuel the
engine inside a building where gasoline fumes may reach flames
or sparks.
You may use regular unleaded gasoline containing no more than
10% Ethanol (E10) or 5% Methanol by volume. In addition,
Methanol must contain cosolvents and corrosion inhibitors. Use of
fuels with content of Ethanol or Methanol greater than shown
above may cause starting and/or performance problems. It may
also damage metal, rubber, and plastic parts of the fuel system.
Engine damage or performance problems that result from using a
fuel with percentages of Ethanol or Methanol greater than shown
above are not covered under warranty.
Gasoline is highly flammable and explosive, and you
can be burned or seriously injured when refueling.
Stop engine and keep heat, sparks, and flame away.
Refuel only outdoors.
Wipe up spills immediately.
Fuel can damage paint and some types of plastic. Be careful not to
spill fuel when filling your fuel tank. Damage caused by spilled
fuel is not covered under the Distributor’s Limited Warranty.
Never use stale or contaminated gasoline or oil/gasoline mixture.
Avoid getting dirt or water in the fuel tank.
With the engine stopped and on a level surface, remove the fuel
filler cap and check the fuel level. Refill the tank if the fuel level
is low.
Add fuel to the bottom of the fuel level limit of the fuel tank. Do
not overfill. Wipe up spilled fuel before starting the engine.
These items should be serviced by your Honda servicing
dealer, unless you have the proper tools and are mechanically
proficient. Refer to the Honda shop manual for service
procedures.
For commercial use, log hours of operation to determine
proper maintenance intervals.
Check that there is no crack and abnormal wear-out in the belt,
and replace if it is abnormal.
Failure to follow this maintenance schedule could result in non-
warrantable failures.
1.
2.
(1)
(2)
(3)
(4)
REGULAR SERVICE PERIOD (3)
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Engine oil
Air cleaner
Sediment cup
Spark plug
Spark arrester
Valve clearance
Timing belt
Combustion
chamber
Fuel tank &
filter
Fuel tube
Check level
Change
Check
Clean
Replace
Clean
Check-adjust
Replace
Clean
Check-adjust
Check
Clean
Clean
Check
Each
Use
Every 6
Months
or
100 Hrs
(1)
(2)
Every
Year
or
300 Hrs
(2)
Every
2 Years
or
500 Hrs
After every 500 Hrs. (2) (4)
After every 500 Hrs. (2)
Every 2 years
(Replace if necessary) (2)
REGULAR SERVICE PERIOD (3)
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Each
Use
First
Month
or
20 Hrs
First
Month
or
20 Hrs
Refer
to
Page
8
9
9
9
10
11
11
Shop
manual
Shop
manual
Shop
manual
Shop
manual
Shop
manual
Engine oil
Air cleaner
Sediment cup
Spark plug
Spark arrester
Valve clearance
Timing belt
Combustion
chamber
Fuel tube
After every 500 Hrs. (2) (4)
After every 500 Hrs. (2)
Every 2 years
(Replace if necessary) (2)
Check level
Change
Check
Clean
Replace
Clean
Check-adjust
Replace
Check-Clean
Check-adjust
Check
Clean
Check
Every
Year
or
300 Hrs
(2)
Every 3
Months
or
50 Hrs
(1)
Refer
to
Page
8
9
10
10
10
11
11
Shop
manual
Shop
manual
Shop
manual
Shop
manual
Every 6
Months
or
100 Hrs
07/06/21 11:43:56 32Z3S600_007