HONDA HHT25S - Manual (Page 14)

14
SERVICING YOUR TRIMMER
Good maintenance is essential for safe, economical, and trouble-free
operation. It will also help reduce air pollution.
To help you properly care for your trimmer, the following pages
include a maintenance schedule, routine inspection procedures, and
simple maintenance procedures using basic hand tools. Other service
tasks that are more difficult, or require special tools, are best handled
by professionals and are normally performed by a Honda technician
or other qualified mechanic.
The maintenance schedule applies to normal operating conditions. If
you operate your trimmer under severe conditions, such as sustained
high-load or high-temperature operation, or use it in unusually wet or
dusty conditions, consult your authorized Honda servicing dealer for
recommendations applicable to your individual needs and use.
Remember that your authorized Honda servicing dealer knows your
trimmer best and is fully equipped to maintain and repair it.
To ensure the best quality and reliability, use only new, Honda
Genuine Parts or their equivalents for repair and replacement.
Maintenance, replacement, or repair of the emission control
devices and systems may be performed by any engine repair
establishment or individual, using parts that are “certified” to
EPA standards.
MAINTENANCE SAFETY
Some of the most important safety precautions follow. However, we
cannot warn you of every conceivable hazard that can arise in
performing maintenance. Only you can decide whether or not you
should perform a given task.
Safety Precautions
• Make sure the engine is off before you begin any maintenance or
repairs. This will eliminate several potential hazards:
— Carbon monoxide poisoning from engine exhaust.
Be sure there is adequate ventilation whenever you operate the
engine.
— Burns from hot parts.
Let the engine and exhaust system cool before touching.
— Injury from moving parts.
Do not run the engine unless instructed to do so.
• Read the instructions before you begin, and make sure you have
the tools and skills required.
• To reduce the possibility of fire or explosion, be careful when
working around gasoline. Use only a nonflammable solvent, not
gasoline, to clean parts. Keep cigarettes, sparks, and flames away
from all fuel-related parts.
MAINTENANCE SCHEDULE
1. Log the hours of operation to determine the proper maintenance
interval.
2. Service more frequently when used in dusty areas.
3. These items should be serviced by an authorized Honda servicing
dealer unless you have the proper tools and are mechanically
proficient. Refer to the Honda shop manual for service procedures.
Failure to follow this maintenance schedule could result in
non-warrantable failures.
B WARNING
Improperly maintaining this trimmer, or failure to correct a
problem before operation, can cause a malfunction in
which you can be seriously hurt or killed.
Always follow the inspection and maintenance
recommendations and schedules in this owner's manual.
B WARNING
Failure to properly follow maintenance instructions and
precautions can cause you to be seriously hurt or killed.
Always follow the procedures and precautions in the
owner's manual.
Interval 1 Item
Before each use Check the engine oil (page 15)
Check the air cleaner (page 15)
Check the throttle cable (page 16)
Check the cutting attachment
Check the debris shield
Check/tighten nuts, bolts, and fasteners
Check the shoulder harness quick release
First month or
10 hours Change the engine oil (page 15)
Every 3 months or
25 hours Clean the air filter element (page 15) 2
Every 6 months or
50 hours Change the engine oil (page 15)
2
Clean the air filter element (page 15)
2
Check/lubricate the drive cable 3
Lubricate the gear case 3
Check the clutch shoes and drum
3
Check the engine cooling fins
Every year or 100
hours Perform the 50-hour service items plus:
Check/adjust the idle speed
3
Check/adjust the valve clearance
3
Check/adjust the spark plug
Check the spark arrester
Check the fuel filter
Clean the fuel tank
Every 2 years or
300 hours Perform the 100-hour service items plus:
Replace the spark plug (page 16)
Clean the combustion chamber
3
Every 2 years Check the fuel tubes and replace if necessary 3
Check the oil tube and replace if necessary 3