Document Outline

• CAFSAttack Installation & Operation, p/n: 209-0020-85-0, Rev-A
  • Apparatus Information
  • Notice !
  • Contents
  • 1 Safety precautions
    • 1.1 General Guidelines
    • 1.2 Air Bottle Cylinders
      • Brief Overview
      • SCBA Fill Station
    • 1.3 Air Filter Element
    • 1.4 Emergency Shut-Down
  • 2 Introduction
    • 2.1 Overview
      • Figure 2-1: CAFSAttack System Overview
    • 2.2 Smart-Switch Controller (SPC)
      • OPEN Button, Discharge Valve
        • Figure 2-2: Smart-Switch Controller - SPC
      • CLOSE Button, Discharge Valve
      • LED Indicator Array (Bar Graph)
      • WET (+) Button
        • Press and Release
        • Press and Hold
        • LED Indicator
      • DRY ( - ) Button
        • Press and Release
        • Press and Hold
        • LED Indicator
    • 2.3 CAFSAttack Operator Control Panel
      • Figure 2-3: CAFSAttack Operator Control Panel
      • CAFS Enable ON/OFF Switch
      • HIGH Pressure Indicator
      • Air Bottle OPEN/CLOSE Valve
      • Intelli-Tank Air Level Indicator
      • Air Bottle FILL Coupling
  • 3 Receiving and inspection
    • 3.1 Receiving
      • Items Furnished
      • Items Required, by Builder/Installer
      • Unpacking
      • Lifting The System
  • 4 Installation - Retrofit Full Size Pumper
    • 4.1 General
      • Figure 4-1: CAFSAttack System Overview
    • 4.2 DOT Air Bottle Cylinder Assembly
      • Figure 4-2: DOT Air Bottle Cylinder Assembly Layout Dimensions
    • 4.3 Pressure Balancing Valve Assembly
      • Figure 4-3: Pressure Balancing (Regulator) Valve Assembly Layout
    • 4.4 Foam Pump Installation
    • 4.5 CAFSAttack Operator Panel Layout
      • Figure 4-4: Operator’s Panel Layout Dimensions
    • 4.6 SVS Discharge Manifold
      • Figure 4-5: Typical CAFSAttack SVS Discharge Manifold Assembly
    • 4.7 Plumbing
      • CAFSAttack Operator’s Control Panel
        • Figure 4-6: Typical HIGH Air Pressure Connections
        • Figure 4-7: 4,500 PSI HIGH Pressure Balancing Regulator and Dome Connections
        • Figure 4-8: Pump-to-Balancer Valve Dome Connection
      • Intake Air Pressure Gauge Layout Option
        • Figure 4-9: Typical Intake Air Pressure Gauge Layout
      • Low Pressure CAFS Connect (2)
        • Figure 4-10: Typical LOW Pressure CAFS Air Connections
      • Air Discharge Moisture Drain
        • Figure 4-11: Typical Discharge Drain
        • Table 4-12: Tubing Size vs. Color
      • CAFS Air LOW Pressure Gauge Layout Option
        • Figure 4-13: CAFS Air LOW Pressure Layout Option
    • 4.8 Electrical
      • Smart-Switch Controller - SPC (S1 and S2)
        • Figure 4-14: Smart-Switch Controller Panel Cutout
        • Figure 4-15: SPC Connector, Back View
      • CAFSAttack Main Wire Harness
        • Figure 4-16: Primary CAFS Wire Harness
      • Primary Power and Ground
      • RFI / EMI
        • Figure 4-17: Extra Cable Storage
      • Flow Sensor Connections (FM1 and FM2)
      • Air Supply Valve, Electric Motor (MV2)
      • Discharge Valve, Electric Motor (MV1)
      • On/Off Switch (SA3), Operator Control Panel
        • Figure 4-18: On/Off Switch Connection
    • 4.9 Installation and Delivery Check List
    • 4.10 Start Up Check List
      • Electrical
      • Air and Water
    • 4.11 System Installer Start-Up
      • Initial System Power Check
      • System Operation Check
        • For FoamLogix
        • For CAFSAttack
  • 5 Preset calibration
    • 5a.1 Smart-Switch calibration
      • Figure 5-1: Smart-Switch Calibration Overview
      • To calibrate a WET consistency...
      • To calibrate a DRY consistency...
  • 5a Basic operation
    • 5a.1 Starting CAFSAttack
    • 5a.2 Shutting-down CAFSAttack
    • 5a.3 Emergency Shut-Down
  • 6 Routine maintenance
    • 6.1 Maintenance Procedures
      • After each use
      • Monthly
      • Every Two (2) Months
      • Annually
    • 6.2 Replace Filter Element
      • Figure 6-1: Filter Pressure Contamination Gauge
    • 6.3 Relieving HIGH PRessure
      • Figure 6-2: Relieving HIGH Pressure
  • Appendix B: Foam Concentrate Compatibility
    • Reference
  • Express Warranty
    • Class1
  • Drawing / Manual Package
    • Drawings, CAFSAttack
    • Manuals
      • EZ-Flow Meter, HLIT 300
      • Intelli-Tank Water-Foam Level display, 106759.pdf
      • Tescom Safety Installation & Operation
  • Class1
  • Return HOME Page
  • Exit