JLG 4394RT Service Manual - Manual (Page 11)

SECTION 1 - SPECIFICATIONS
3121133 – JLG Sizzor – 1-1
SECTION 1. SPECIFICATIONS
1.1 SPECIFICATIONS 1.2 CAPACITIES
1.3 ENGINES
Table 1-1. Operating Specifications
Description 3394RT 4394RT
Maximum Occupants 6
Maximum Workload
(Capacity):
Single Extension:
Dual Extension:
Extension Only:
2250 lbs (1020 kg)
2000 lbs (905 kg)
500 lbs (230 kg)
1500 lbs (680 kg)
1250 lbs (565 kg)
500 lbs (230 kg)
Maximum Travel Grade :
2 WD
4WD
35%
45%
Maximum Travel Grade : 3°
Maximum Platform Height 33 ft 43 ft
Maximum Drive Speed 2 WD
Maximum Drive Speed 4WD 3.0 mph (4.8 kph)
3.5 mph (5.6 kph) 3.0 mph (4.8 kph)
3.5 mph (5.6 kph)
LIft Up Speed (Stowed to Full
Height)
29 - 31 sec 40 - 45 sec
Lift Down Speed (Full Height
to Stowed)
Maximum Wind Speed 28 mph (12.5 m/s)
Maximum Horizontal Manual
Side Force:
Single Extension
Dual Extension
Single Extension (CE/AUS)
Dual Extension (CE/AUS)
335 lb force (1490 N)
300 lb force (1335 N)
90 lb force (400 N)
90 lb force (400 N)
300 lb force (1335 N)
300 lb force (1335 N)
90 lb force (400 N)
90 lb force (400 N)
Maximum Tire Load 4400 lbs (1996 kg)
Ground Bearing Pressure
w/Standard tires
49 psi
(3.45 kg/cm 2 )
56 psi
(3.94 kg/cm 2 )
Leveling Jack Bearing
Pressure
69 psi (4.9 kg/cm
2
)
Wheelbase 9.67 ft (2.95 m)
Ground Clearance 12 in (30 cm)
Maximum Hydraulic System
Pressure 3000 psi (207 bar)
Electrical System Voltage 12 Volt
Inside Turning Radius 14 ft 5 in (4.39 m)
Outside Turning Radius 20 ft 1 in (6.12 m)
Gross Vehicle Weight w/ One
Extension
Note: Certain options or
country standards increase
weight.
11,910 lbs
(5,402 kg)
15,300 lbs
(6,940 kg)
Table 1-2. Capacities
Description 3394RT 4394RT
Fuel Tank 31.5 gal (119 l)
Hydraulic Tank 40 gal (151 l)
Table 1-3. Ford LRG-425 Specifications
Fuel Gasoline
Oil Capacity 4.5 Quarts (4.25 L) w/Filter
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 40 Amp, Belt Drive
Battery 112 Amphour, 950 Cold Cranking
Amps, 12 VDC
Fuel Consumption
Low RPM
High RPM
3.45 GPH (13.06 lph)
4.60 GPH (17.41 lph)
Horsepower 54 @ 2400 RPM, full load
Cooling System 16 Quarts (15.14 L)
Spark Plug AWSF-52-C
Spark Plug Gap 0.044 in. (1.117 mm)
Table 1-4. Deutz F3M2011 Specifications
Fuel DIesel
Oil Capacity 8.5 Quarts (8 L) w/Filter
Low RPM 900
High RPM 2800
Alternator 95 Amp, Belt Drive
Battery 112 Amphour, 950 Cold Cranking
Amps, 12 VDC
Fuel Consumption
Low RPM
High RPM
1.3 GPH (4.9 lph)
1.6 GPH (6.0 lph)
Horsepower 48 @ 2800 RPM, full load