JLG M400 Service Manual Service Manual - Manual (Page 15)

SECTION 1 - SPECIFICATIONS
3121827 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 OPERATING SPECIFICATIONS
1.2 CAPACITIES
1.3 BATTERY CHARGER
1.4 DRIVE SYSTEM
1.5 HYDRAULIC PUMP/ELECTRIC MOTOR
ASSEMBLY
1.6 GENERATOR
1.7 TIRES
Table 1-1. Operating Specifications
Maximum Work Load (Capacity)
Unrestricted:
500 lb. (230 kg)
Maximum Travel Grade (Gradeablility 30%
Maximum Travel Grade (Side Slope) 5°
Machine Weight (GVW)
E400Anarrow
M400Anarrow
E400AJP
M400AJP
E400AJPnarrow
M400AJPnarrow
13100 lbs. (5942 kg)
13300 lbs. (6033 kg)
13700 lbs. (6214 kg)
13930 lbs. (6318 kg)
14900 lbs. (6759 kg)
15130 lbs. (6862 kg)
System Voltage 48 volts
Battery Life per Charge 7 hours continuous
Battery Recharge Time
Charger
Generator
17 hours from full discharge
6.2 hours
Table 1-2. Capacities
Generator Fuel Tank 4 Gallons (15.1 L)
Hydraulic Oil Tank
E/M 400A, E/M 400Anarrow
E/M400AJP, E/M400AJPnarrow
4 gallons. (15.14 liters)
5 Gallons (19 L)
Hydraulic System (Including Tank) 9 Gallons (34.1 L)
Torque Hub, Drive
*
19 ounces (0.50 L)
*Torque hubs should be one half full of lubricant.
Table 1-3. Battery Charger
Input 110 VAC,60 HZ
Output 48 VDC (25 Amps)
Batteries (8) 6 Volt, 370 Amp Hour (20 hour rate)
Table 1-4. Drive System
Drive Motor 48 VDC, 12.5 H.P. @ 3200 rpm.
continuous, rotation - reversible
Drive Brake- spring-applied, hydrauli-
cally released Drive Brake- spring-applied,
hydraulically released
Table 1-5. Hydraulic Pump/Electric Motor Assembly
Motor 48 VDC, 2.14 H.P. @ 2700 rpm.
Pump 0.098 in.[3]/rev. (1.6 cm[3]/rev.).
Pump Output 2.96 gpm (11.2 lpm) @ 3400 psi (234 Bar).
Table 1-6. Generator
Alternator Output 58 volts @ 45 Amps
RPM’s under max. load 3100
Start Battery 12 volts
Engine Oil 10W30 (Refer to Engine Manual)
Dynamo 12 volt, 15 amp DC
Dynamo Output Fuse 20 amps DC
Control Fuse 15 amps DC
Table 1-7. Tire Data
Size
E/M400A, E/M400AJP 240/55 - 17.5 Pneu. non marking
240/55 - 17.5 Foam Filled
26 x 7 x 20 non marking
240/55 - 17.5 Pneu.
240/55 - Foam Filled
Size
E/M400Anarrow, E/M400AJPnarrow 25 x 7 x 12 - non marking
22 x 6 x 17.5 - non marking
Tire Pressure (pneumatic) 90 psi. (6.2 Bar)
Max. Tire Load
E/M 400Anarrow
E/M400AJP
E/M400AJPnarrow
5160 lbs. (2343 kg)
6300 lbs. (2860 kg)
7200 lbs. (3268 kg)
Ground Bearing Pressure
E/M 400A
E/M 400Anarrow
E/M400AJP
E/M400AJPnarrow
80 psi (5.6kg/cm 2 )
95 psi (6.6 kg/cm 2 )
80 psi (5.6 kg/cm 2 )
185 psi (13.0 kg/cm 2 )