Countax D50 - Manual (Page 21)

Page 21
Engine - Fuel & Air Filter
FUEL FILTER
Replace the fuel filter after 400 hours of use or annually
(Part No. 1182005510). Follow this procedure:
• Loosen the inlet and outlet port clip of filter and remove pipe.
• Remove the fuel filter by pulling it towards you.
• Install a new fuel filter to the support.
• Attach the inlet/outlet pipe to the fuel filter.
AIR BLEEDING FROM FUEL SYSTEM
By starting your D18/50 the solenoid pump is actuated to bleed
air automatically from the fuel system.
AIR CLEANER ELEMENT CLEANING AND
REPLACEMENT
Clean the air cleaner element once every 50 hours and replace it
every 200 hours.
1. Remove the air cleaner cover and element.
2. Blow the element with compressed air (7kg/cm or below) to
remove dust.
3. Clean inside the case any dust and dirt and install the element.
4. Always ensure that seal is in place.
Always replace excessively used or damaged filter elements
Part No. 11840012520.
BONNET AIR VENTS
It is very important to regularly check and clean the side air vents
located on either side of the bonnet of your D18/50 tractor.
RADIATOR GRILL
Check and clean on every refuelling, see fig 4.
fig 1
Keep
clear of dirt
fig 3
fig 2
Removal of
Air filter
Fuel
Filter
fig 4
Clean the radiator
grill using a soft
brush, taking care
not to damage the
radiator
Remove the
guard on radiator by
loosening the 3
screws using a
10mm spanner
Air cleaner
cover
Prefilter
Filter
element
Seal