Multiquip Pump QP-3TH - Manual

The following instructions are intended to assist the user
in starting the QP-3TH Pump. Please read the entire
instructions before starting.
QP-3TH Pump
Starting Instructions
Before Starting
„ Place pump as near to water as possible, on a firm flat, level
surface.
„ To prime pump, remove fill cap and fill pump casing with
water. If the pump casing is not filled with water before starting,
it will not begin pumping.
„
Check for leaks between pump and engine.
„ Check that all hoses are securely attached to the pump.
„ Check that the discharge hose is not restricted.
„ Make sure the suction strainer is clean and securely
attached to the water end of the suction hose.
DO NOT open fill cap if pump is hot! Water inside may be
under pressure.
WARNING WARNING WARNING WARNING WARNING
2. Move the throttle lever (Figure 2) away from the slow
position, about 1/3 of the way toward the fast position.
Figure 1. Engine Fuel Valve Lever (ON Position)
Figure 2. Throttle Lever (1/3 Start Position)
„ NEVER! operate the pump without water in the casing as
this will cause damage to the mechanical seal.
„ The strainer should be positioned so it will remain
completely under water. Running the pump with the
strainer above water for long periods can damage the pump.
CAUTION CAUTION CAUTION CAUTION CAUTION
Starting the Engine
1. Place the engine fuel valve lever (Figure 1) to the "ON"
position.
3. Place the choke lever (Figure 3) in the "OPEN " position if
starting a cold engine.
4. Place the choke lever (Figure 4) in the "CLOSED " position
if starting a warm engine or the temperature is warm.
Figure 3. Engine Choke Lever (Open)
Figure 4. Engine Choke Lever (Closed)
5. Place the engine ON/OFF switch (Figure 5) in the "ON "
position.
Figure 5. Engine ON/OFF Switch (ON Position)
DO NOT pump flammable fluids, corrosive chemicals or fluids
containing toxic substances. These fluids can create potentially
dangerous health and environmental hazards. Contact local
authorities for assistance.
DANGER DANGER DANGER DANGER DANGER