Multiquip TRASH PUMP (hatz 1B40u-2203a diesel engine) Qp4tZt10p - Manual (Page 9)

qp4TzT10p/TMp16F/TMpXF Trash puMp • operaTion & parTs Manual — rev. #1 (08/29/11) — page 9
saFety inFOrMatiOn
BaTTerY saFeTY (eleCTriC sTarT onlY)
Danger
 Do noT drop the battery. There is a possibility that the
battery will explode.
 Do noT expose the battery to open fl ames,
sparks, cigarettes, etc. The battery contains
combustible gases and liquids. If these
gases and liquids come into contact with
a fl ame or spark, an explosion could occur.
Warning
 alWaYs wear safety glasses when
handling the battery to avoid eye irritation.
The battery contains acids that can cause
injury to the eyes and skin.
 Use well-insulated gloves when picking up
the battery.
 alWaYs keep the battery charged. If the battery is not
charged, combustible gas will build up.
 Do noT charge battery if frozen. Battery can explode.
When frozen, warm the battery to at least 61°F (16°C).
 alWaYs recharge the battery in a well-ventilated
environment to avoid the risk of a dangerous concentration
of combustible gases.
 If the battery liquid (dilute sulfuric acid)
comes into contact with clothing or skin,
rinse skin or clothing immediately with
plenty of water.
 If the battery liquid (dilute sulfuric acid) comes into
contact with eyes, rinse eyes immediately with plenty
of water and contact the nearest doctor or hospital to
seek medical attention.
CauTion
 alWaYs disconnect the negaTive battery terminal
before performing service on the equipment.
 alWaYs keep battery cables in good working condition.
Repair or replace all worn cables.
TransporTing saFeTY
CauTion
 NEVER allow any person or animal to stand underneath
the equipment while lifting.
NOTICE
 Before lifting, make sure that the equipment parts are not
damaged and screws are not loose or missing.
 alWaYs make sure forklift forks are inserted into pockets
(if applicable) as far as possible when lifting the pump.
 alWaYs shutdown engine before transporting.
 never lift the equipment while the engine is running.
 Tighten fuel tank cap securely and close fuel cock to
prevent fuel from spilling.
 Use one point suspension hook and lift straight upwards.
 Do noT lift machine to unnecessary heights.
 alWaYs tie down equipment during transport by
securing the equipment with rope.
 Never allow any person or animal to stand underneath the
equipment while lifting.