Land Pride 4400ex - Manual (Page 32)

Section 6: Maintenance
4400EX Heavy Duty Off Road Utility Vehicle 720-051M 6/30/05 30
Table of Contents
(1) Reservoir should be 3/4 full when all hydraulic accessories are in retract position.
(2) Replace air cleaner pre-cleaner if damaged.
(3) Check tightness after first 2 hours of initial operation and 2 hours after removal for repair and/or replacement.
(4) Replace paper element if extremely dirty or damaged.
(5) Make first oil and filter change after the first month of operation or at 20 hours of operation (whichever comes first).
Maintenance Schedule
Maintenance Operation Daily
Every
25
Hrs
Every
100
Hrs.
Every
200
Hrs.
Every
6
Mos.
Every
Season
Refer
to
Page
Check Engine Oil level X 31
Check Hydraulic Fluid Level (1) X 35
Check Tire Pressure X 23
Check for Fluid Leaks X
Inspect All Nuts and Bolts for Tightness X 22
Check and Clean Area Around Air Intake X 28
Grease Zerk Fittings for rotating surfaces - 2
places X 36
Service Air Cleaner Pre-cleaner Foam
Element(2) X 28
Check Wheel Lug Nuts (Torque 65 to 75 Ft.
lbs.) (3) X 22
Grease Zerk Fittings for bearings - 3 places X 35 & 36
Service Air cleaner Paper Element (4) X 28
Change Engine Oil (5) & (6) X X 32
Change Engine Oil Filter (5) & (6) X X 32
Check Differential Fluid Level (7) X X 33
Check Transmission Fluid Level (8) X X 34
Check Battery Charge and Water Level X 23
Inspect Drum Brakes X
Inspect Parking Brake X
Check Master Cylinder Brake Fluid X 34
Check & Regap Spark Plugs (1.02 mm / .04 in.) X
Check Fuel Line Hoses and Clamps X 26
Replace In-line Fuel Filter X 26
Clean Battery and Terminals X 23
Check Power Steering Belt X 27
Clean Spark Arrester (9) X 29
Service Bendix starter drive (10) X
Disassemble and clean solenoid shift starter
(10) X