Land Pride 311-252M - Manual (Page 2)

Table of Contents
RTA10 & RTA15 Series Rotary Tillers 311-252M 5/17/13
© Copyright 2013 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use
of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this
product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Section 1: Assembly & Set-Up . . . . . . . . . . . . 8
Dealer Preparations . . . . . . . . . . . . . . . . . . . . . . . . 8
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . . 8
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . . 8
Parking Stand Assembly . . . . . . . . . . . . . . . . . . . . . 8
Hitch, Driveline Guard & Rear Chain . . . . . . . . . . . . 9
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 11
Check Driveline Collapsible Length . . . . . . . . . . 12
Shorten Driveline . . . . . . . . . . . . . . . . . . . . . . . . 12
Check Driveline Maximum Length . . . . . . . . . . . 13
Check Driveline Interference . . . . . . . . . . . . . . . 13
Section 2: Operating . . . . . . . . . . . . . . . . . . . 14
Operating Checklist . . . . . . . . . . . . . . . . . . . . . . . . 14
Inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 14
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
General Operating Notes . . . . . . . . . . . . . . . . . . . . 16
General Operating Instructions . . . . . . . . . . . . . . . 17
Section 3: Adjustments . . . . . . . . . . . . . . . . . 18
RTA10 Tiller Hitch Offset . . . . . . . . . . . . . . . . . . . . 18
RTA15 Tiller Hitch Sideshift . . . . . . . . . . . . . . . . . 18
Drive Chain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Rear Deflector . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Skid Shoe Adjustment . . . . . . . . . . . . . . . . . . . . . . 20
Section 4: Maintenance & Lubrication . . . . . 21
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Tine Replacement . . . . . . . . . . . . . . . . . . . . . . . . . 21
Driveline Protection . . . . . . . . . . . . . . . . . . . . . . . . 21
Clutches With 4 Adjusting Nuts . . . . . . . . . . . . . . . 21
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Clutch Disassembly & Assembly . . . . . . . . . . . . 22
Clutches With 8 Hex Socket Bolts . . . . . . . . . . . . . 23
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Clutch Disassembly & Assembly . . . . . . . . . . . . 23
Shearbolt Protection . . . . . . . . . . . . . . . . . . . . . . . 23
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Driveline U-Joint . . . . . . . . . . . . . . . . . . . . . . . . . 25
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Chaincase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Bearing On Right End Of Rotor Shaft . . . . . . . . . 26
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Section 5: Specifications & Capacities . . . . . 27
Section 6: Features & Benefits . . . . . . . . . . . 29
Section 7: Troubleshooting . . . . . . . . . . . . . . 31
Section 8: Torque Values Chart . . . . . . . . . . 32
Section 9: Warranty . . . . . . . . . . . . . . . . . . . . 33
Table of Contents