S&B Filters Cold Air Intake Kit - Cotton Filter 75-5021 User Manual
Installation instructions
1.
With the ignition switched off, place
vehicle in Park and or set Parking Brake.
Then disconnect both negative battery
cable.
Installation Instructions
Vehicle Applications
Year: 2007-2008 Chevrolet
Make: Chevy/ GMC
Model: Silverado 1500
Sierra 1500
Engine: V8 4.8L, 5.3L, 6.0L
15461 Slover Ave., Fontana, CA 92337 - Phone: (909) 947-0015 - Fax: (909) 947-0603 -
4.
Pull the crankcase breather line from
the OE intake tube and from the engine and
remove.
7.
Slide the OE air box towards the engine
while pulling up, to remove from vehicle.
2.
Pull up and out to remove the engine
cover from the vehicle.
5.
Pry the OE plastic radiator hose binder
from the intake tube .
8.
Loosen the hose clamp on the OE air box
and remove the MAF sensor.
Note: Direction of arrow with regards to flow.
3.
Disconnect the electrical connection to
the MAF sensor at the OE air box.
6.
Loosen the hose clamp at the throttle
body and at the MAF sensor, remove the OE
intake tube from the engine.
9.
Place the S&B filter (D) inside the S&B
air box (H), then attach the filter adapter (I) to
the box using the 5/16 screws (J).
P/N: 75-5021 / 75-5021D
SEE EXPLODED VIEW ON PAGE 4
1
Tools required
• 10mm Wrench & Socket
• 5/16” Nut Driver or Flat Blade Screwdriver
• Phillips Screwdriver, Pliers or Channel locks
Notes
Kit may not fit with the following
Aftermarket Parts installed:
• Body Lift or Lowering Kit
• Custom Hood
• Throttle Body Spacer/ Upgrade
Before You Start
• Please read the entire product guide before proceeding.
• Ensure all components listed on page 4 are present.
• If you are missing any of the components, call our customer
support at (909) 947-0015.
• Do not work on your vehicle while engine is hot.
• Make sure the engine is turned off and the vehicle is in Park or
the Parking Brake is set.
CARB Status - Exempt
CARB EO #: D-590-5
Legal for use in CA or other states
adopting CA emissions standards
See Page 3 for more info.
S&B Filter Maintenance
Cleanable
(KF-1035)
. If the enclosed filter is Red, it came pre-oiled
from the factory. Please visit
for exact oil
amount required after cleaning.
Disposable
(KF-1035D)
. If the enclosed filter is White, it is a
disposable filter and should be discarded once it reaches capacity.
This filter
(does not require oil)
. For more info on S&Bʼs disposable
filter, visit
.