Castle TSM-35 Serial 63658 and higher Assembly Drawing & Parts - Manual (Page 11)

Item # Part # Part Description Qty Item # Part # Part Description Qty
1 Control Panel Enclosure Assembly 9 Pressure Sensor Switch
M00134 Control Panel Enclosure 1 E35420 Switch, Air Pressure Sensing 1
F14225 Screw, Hex Head Cap. 1/4-20 x 1 ZP 4 D22181 Terminal, 22-18 Fully Insulated, Female 2
F01420 Nut, Nylon Lock, 1/4-20 ZP 4 P33228 Fitting, 10-32 x 1/16 Barb, Black Nylon 1
S17578 Label, Caution, "Wear Safety Glasses" 1 P01418 Tubing, 1/4 OD x 1/8 ID, Black Urethane 1"
S13264 Label, Warning, "Danger Electrical Hazard" 1
S11635 Label, "Made in USA" 1 10 F38241 Nut, Hex Jam, 3/8-24 ZP 1
S35002 Label, Wiring Diagram 1
D06627 Cable Tie Anchor, White Nylon, W/ Adhesive 2 11 Control Panel Back Plate
M35013 Control Panel Back Plate 1
2 C30351 Start Switch Actuator Assembly F14212 Carriage Bolt, 1/4-20 x 1/2 ZP 2
E03041 3SB3000-0AA41 Start Switch 1 F01423 Nut, Hex, 1/4-20 ZP 2
E03400 Normally Open Contact Block 1
12 Contol Panel Back Plate Slot Cover
3 C30352 Stop Switch Actuator Assembly M00130 Back Plate Slot Cover 1
E03000 3SB3000-1XA20 Stop Switch 1 F08324 Screw, Pan Phillips Machine, 8-32 x 3/4 ZP 4
E03401 Normally Closed Contact Block 1 F08132 Nut, Lock Washer, 8-32 Kep ZP 4
S11436 Tape, PVC Foam S/A 1-1/4" 7.2"
4 E35424 Control Board, EL-35D 1
13 Transformer Assembly
5 Control Board Mounting Assembly E35713 Transformer,50VA,Multi-Input,24VAC Output 1
D08012 1/4 x 1/2 #8 Plastic Spacer 4 E16224 Fuse, 250V 1
F08100 Screw, Pan Head Phillips, 8-32 x 1 ZP 4 D82218 Vinyl Spade Lug, 22-18 #8 2
F08132 Nut, Lock Washer, 8-32 Kep ZP 4 E18373 Wire, 18AWG Hookup Blue 16.5"
E18371 Wire, 18AWG Hookup Grey 17
6 D12001 Clamp Connector & Nut, Romex 3/8-1/2 KO 1 D81614 Vinyl Spade Lug, 16-14 #8 2
D61614 Vinyl Ring Lug, 16-14 #8 1
7 H12516 Grommet, Black Rubber, 5/16 ID x 1/2 OD 1 E18374 Wire, 18AWG Hookup Orange 27"
F08324 Screw, Pan Phillips Machine, 8-32 x 3/4 ZP 3
8 Strain Relief F08100 Screw, Pan Phillips Machine, 8-32 x 1" ZP 1
D49600 90 Degree Cord Grip 1 F08132 Nut, Lock Washer, 8-32 Kep ZP 4
E03185 1/2 Conduit Locknut 1
Drawing 5 of 5 - Control Panel Assembly