Blue Angel Pumps 63042-BLA1 - Manual

2 HP Grinder Pump
332304-002 10/09
REMINDER: Keep your dated proof of purchase for warranty purposes! Attach it to this manual or file it for safekeeping.
Figure 1
Description
The 2 HP Grinder is a submersible
wastewater pump designed specifically
for pumping domestic sewage. One
pump can handle the sewage for a
maximum of 2 homes. These pumps are
not to be used for pumping commercial
or industrial sewage from factories,
schools, motels, apartments, etc. This
pump is not for use in hazardous
locations!
UNPAcKING AND INsPEcTIoN
Inspect this unit before it is used.
Occasionally, products are damaged
during shipment. If the pump or
components are damaged, return
the unit to the place of purchase for
replacement. Failure to do so could
result in serious injury or death.
safety Guidelines
This manual contains information that is
very important to know and understand.
This information is provided for SAFETY
and to PREVENT EQUIPMENT PROBLEMS.
To help recognize this information,
observe the following symbols.
Danger indicates an
imminently
hazardous situation which, if not avoided,
will result in death or serious injury.
Warning indicates a
potentially
hazardous situation which, if not avoided,
could result in death or serious injury.
Caution indicates a
potentially hazardous
situation which, if not avoided, may result
in minor or moderate injury.
Notice indicates
important
information, that if not followed, may
cause damage to equipment.
NoTE: Information that requires special
attention.
General safety
Information
cAlIFoRNIA PRoPosITIoN 65
This product or its
power cord may
contain chemicals known to the State
of California to cause cancer and birth
defects or other reproductive harm.
Wash hands after handling.
1. Know the pump application,
limitations and potential hazards.
Do not use to
pump flammable or
explosive fluids such as gasoline, fuel oil,
kerosene, etc. Do not use in flammable
and/or explosive atmospheres. Use to
pump only with liquids compatible with
pump components materials. Failure
to follow this warning can result in
personal injury and/or property damage.
2. Only qualified personnel should
install, operate and repair this pump.
3. Make certain that the power source
conforms to the requirement of the
equipment.
Disconnect power
before servicing. If
the power disconnect is out of sight,
lock in the open position and tag it
to prevent unexpected application of
power. Failure to do so could result in
fatal electrical shock!
4. Release all pressure within the
system before servicing any
component.
5. Drain all liquids from the system
before servicing.
This pump contains
dielectric motor oil
for motor heat transfer. Care should be
taken when disposing of this oil. Do
not use this pump in ponds or fountains
because the motor oil can be harmful to
aquatic life.
6. Check your local codes before installing.
You must comply with local rules.
operating Instructions 2 HP Grinder Pumps
7. Vent any sewage or septic tank
according to local codes.
8. Always keep the shut-off valve
completely open when the system
is in operation (unless advised
otherwise by the proper authorities).
Before removing the pump form the
basin, be sure to close the shut-off
valve. (This prevents back-flow from
the pressure sewer.)
9. Keep the control panel locked or
confined to prevent unauthorized
access to it.
10. Secure the discharge line before
starting the pump. An unsecured
discharge line will whip, possibly
causing personal injury and/or
property damage.
11. Periodically inspect the pump
and system components. Perform
maintenance as required. If the
pump is idle for long periods
of time, add water to the basin
occasionally to start the pump.
Please read and save these instructions. Read carefully before attempting to assemble, install,
operate or maintain the product described. Protect yourself and others by observing all safety
information. Failure to comply with instructions could result in personal injury and/or property
damage! Retain instructions for future reference.
© 2009 Blue Angel ™ Pumps For parts, product & service information
visit www.waynewatersystems.com