Pre-installation planning, Basic frp installation steps – Crane Composites CLEANROOM WALL SYSTEM User Manual

Page 5

Advertising
background image

ADHESIVE RECOMMENDATIONS FOR VARIOUS SUBSTRATES

Refer to form #6846 for additional Crane Adhesive installation information.

Pre-Installation Planning

• Pre-fi t each panel before fastening and/or adhering in place.

All cutting and drilling should be done prior to the application of adhesive.

Preplan for cove or base molding. FRP panels should be installed so that the bas e molding will not restrict normal panel movement
during expansion and contraction. Cut panels 1/4” short of where the base molding will extend; poured acrylic fl oor with built-in
base cove should be in place prior to installation.

When using rivets, pre-drill holes in the panels using a drill bit that is 1/4” larger than the rivet. Plan ahead so that fasteners will not
interfere with moldings or other wall fi xtures.

When using mechanical fasteners through FRP to attach wall angles or other fi xtures, pre-drill holes using a drill bit that is 1/4”
larger than the mechanical fastener. Without oversizing the holes, the FRP will likely have bulges and/or buckles when panel
movement occurs during expansion and contraction.

Basic FRP Installation Steps

1. Trim panel to fi t. Oversize pilot holes if drop-in ceiling wall angle is attached to and through FRP

(please allow for proper expansion and contraction)

2. Radius corners of any cut out fi xture openings.
3. Apply adhesive to 100% of the backside of panel using a cross-hatch pattern using a trowel recommended by the adhesive

manufacturer.

4. Place panel on wall, leaving appropriate room at panel joints and corners for expansion and contraction.
5. Using a laminate roller, remove air pockets by rolling down and out toward the panel edge without a molding.
6. Fit appropriate moldings to panels edge leaving a minimum of 1/8” for expansion between panel and molding stem.
7. Install next panel.

The nature of FRP panels is to expand and contract. Without leaving required room for expansion and contraction, FRP
panels can develop buckles and/or bulges because panel movement will occur.

FRP to:

Advanced

Polymer

Fast Grab

Standard unpainted drywall

YES

YES

Standard unpainted plywood

YES

YES

Treated plywood

YES

NO

Fire rated plywood

YES

NO

Cement board

YES

NO

Fiberglass faced, mold resistant

and fi recode core drywall

YES

NO

DensGlass

YES

NO

FRP

YES

NO

Traditional Greenboard

YES

NO

Ceramic tile

YES

NO

FRP to:

Advanced

Polymer

Fast Grab

Stainless steel

YES

NO

Metal

YES

NO

Aluminum

YES

NO

Galvanized metal

YES

NO

Cement block

(above grade or inside wall)

YES

NO

Cement block

(below grade or outside wall)

YES

NO

Painted walls

(if paint is well anchored)

YES

NO

Polystyrene foam

YES

NO

Polyurethane foam

YES

NO

Foil-faced insulation

YES

NO

5

Advertising