ACE Controls ACE MLS 64 Adjustable Series - Manual

Series
33, 36
45
64
Air-Oil Tank
AO-1
AO-1
AO-3
Air-Oil Tank Installation Instructions
Magnum Group Shock Absorbers
ACE MCA, MCS 33, 36, 45 and 64 Self-Compensating Series
ACE MAA, MAS, MLA, MLS 33, 36, 45 and 64 Adjustable Series
AIR-OIL TANK INSTALLATION (Figure 1)
Self-compensating models MCA and MCS as well as
adjustable models MAA, MAS, MLA and MLS are
pre-filled with ATF but must be connected to an
air-oil tank before use.
Install the proper ACE air-oil tank as close as possible
to, and physically higher than, the shock absorber. The
line connecting the shock absorber to the air-oil tank
must be free of kinks and loops. The inside diameter
of this line must be equal to, or greater than, that of the
port in the shock absorber.
Do not put a shut-off valve between the shock absorber
and the air-oil tank. Install a check valve in the air line
to the air-oil tank and plug the extra ports of the tank.
Fill the tank with ATF to the fill mark, with the rod
extended, and charge the system to between 50-100 psi
(3.4 - 6.8 bar)
AIR EXHAUST CIRCUIT FOR MODELS MCA, MAA
and MLA SHOCK ABSORBERS (Figure 2)
If the rod is to remain in the shock absorber after
decelerating the load, this type of installation is
necessary. If not built in, a special ACE check valve
should be used to eliminate misting of oil out of the
air-oil tank.
PROPER AIR-OIL TANK SIZE
Refer to the chart below for proper air-oil tank size in
relation to the specific Magnum Group series.
Maximum efficiency of operation can be obtained by
carefully following these instructions:
23435 Industrial Park Drive
Farmington Hills, Michigan 48335
tel: 248.476.0213
fax: 248.476.2470
www.acecontrols.com
Figure 2
Air-Oil Tank
CV 3/8-F
above this line Do not fill
WARNING Do not use near open flame
contents may be flammable
3-Way Normal
Closed Valve
Figure 1
Fill Plug
Plug
Plug
Check Valve
Regulator
above this line
Do not fill
WARNING Do not use near open flame
contents may be flammable
Free
Flow
Inlet Port
Air-Oil Tank
(Re-circulating Circuit)
AO-3
AO-3
AO-6-91
M A 4 5 5 0 2
C O N T R O L S I N C .
Air-Oil Tank
World leader in deceleration technology
ISO 9001:2000 Certified
ACE Controls Inc.
Exhaust
Sol
Filter/
Regulator
Supply