Gradall 534D-10 Service Manual - Manual (Page 17)

Form No. 20219 z z z z z 534D-9/534D-10 Owner/Operator Manual
2.5
Located on left side of boom
P/N 9100-3031
OUTSIDE THE CAB
Located on mudguard
P/N 9134-3073
Located on boom head
P/N 9055-3026
Located on attachment
P/N 9015-3001
Located on mudguard
P/N 9055-3027
Located on Personnel Work Platform
P/N 9055-3032
Located on Personnel Work Platform
P/N 9055-3031
Located on Personnel Work Platform
P/N 9055-3033
Located on boom head
P/N 9114-3290
9055-3027 REV. A
READ AND UNDERSTAND THE FOLLOWING PRIOR TO LIFTING PERSONNEL.
WHEN LIFTING PERSONNEL USE ONLY A GRADALL MANUFACTURED PERSONNEL WORK PLATFORM.
DO NOT DRIVE MACHINE WITH PERSONNEL IN PLATFORM.
WHEN PERSONNEL ARE IN PLATFORM REMAIN SEATED IN CAB WITH PERSONNEL
IN DIRECT LINE OF SIGHT.
OPERATE CONTROLS LIGHTLY AND CAUTIOUSLY WHEN LIFTING PERSONNEL.
READ AND UNDERSTAND PERSONNEL WORK PLATFORM USER'S MANUAL BEFORE LIFTING PERSONNEL.
DO NOT USE PERSONNEL WORK PLATFORM WITHOUT THE PROPER GRADALL MATERIAL
HANDLER/PERSONNEL WORK PLATFORM CAPACITY CHART DISPLAYED IN CAB.
FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY OR DEATH.
406 MILL AVE. S.W. NEW PHILADELPHIA, OHIO MADE IN U. S. A.
THE CAPACITY OF FORKLIFT, ATTACHMENT AND FORK
COMBINATION MAY BE LESS THAN THE CAPACITY SHOWN
ON ATTACHMENT - CONSULT FORKLIFT NAMEPLATE
AND ALSO INSURE FORKS ARE OF PROPER SIZE.
9015-3001
ATTACHMENT
SERIAL NUMBER
WEIGHT
CAPACITY
HYD. PRESSURE
ATTACH LANYARD HERE
9055-3032
9055-3026 REV. A
READ AND UNDERSTAND THE FOLLOWING PRIOR TO LIFTING PERSONNEL.
WHEN LIFTING PERSONNEL USE ONLY A GRADALL MANUFACTURED
PERSONNEL WORK PLATFORM.
ALL PERSONNEL IN PLATFORM MUST WEAR A FULL BODY HARNESS WITH
LANYARD ATTACHED TO A DESIGNATED ANCHORAGE POINT.
READ AND UNDERSTAND PERSONNEL WORK PLATFORM USER'S MANUAL
BEFORE OCCUPYING PERSONNEL WORK PLATFORM.
FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY OR DEATH.
9055-3031 REV. A
MAXIMUM OCCUPANCY THREE (3) PEOPLE.
DO NOT USE PERSONNEL WORK PLATFORM
WITHOUT THE PROPER GRADALL MATERIAL
HANDLER/PERSONNEL WORK PLATFORM
CAPACITY CHART DISPLAYED IN CAB.
FAILURE TO COMPLY COULD RESULT IN
SERIOUS INJURY OR DEATH.
406 MILL AVE. S.W. NEW PHILADELPHIA, OHIO MADE IN U. S. A.
DO NOT USE PERSONNEL WORK PLATFORM WITHOUT THE
PROPER GRADALL MATERIAL HANDLER/PERSONNEL WORK
PLATFORM CAPACITY CHART DISPLAYED IN CAB.
9055-3033
ATTACHMENT
SERIAL NUMBER
WEIGHT
CAPACITY
HYD. PRESSURE
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
REAR AXLE WHEEL END LUBE(4 PT.)
TIRES: 14.00x24(12 PLY) 65 PSI
FRONT AXLE
(5 GAL)
MOBIL 424
MOBIL 424
BATTERY & TERMINALS
DIESEL ENGINE
AIR CLEANER ELEMENTS
FUEL FILTERS
OIL FILTER
OIL (12 QT.)
DIESEL FUEL (40 GAL.)
HYD.TANK BREATHER/FILTER CAP
QUICK SWITCH (1) FITTING
TIRES: RADIAL 70 PSI
FRONT AXLE PIVOT (2) FITTINGS
ALL BEARINGS PADS
HEAD PIN (2) FITTINGS
ANNUALLY
OR
1500 HRS
DAILY
OR
10 HRS
WEEKLY
OR
50 HRS
EVERY
5WKS OR
250 HRS
3 MO.
OR
500 HRS
SERVICE INTERVALS
TYPE OR
EQUIVALENT
RADIATOR
3 GAL. WATER
3 GAL ANTI-FREEZE
WHEEL NUT TORQUE-350/400 FT-LBS
9134-3073 REV -
TIRES: 13.00x24(12 PLY) 65 PSI
CHECK
INSPECT
CHECK
REAR AXLE (12) FITTINGS
BOOM PIVOT (2) FITTINGS
TORQUE
CHECK
CHANGE
CYLINDER FITTINGS EACH END
RETRACT & EXTEND CABLE
SEE OPERATOR & MAINTENANCE MANUAL
CHANGE
CHANGE
CHANGE
FILL
OIL (47 GAL.) CHECK
GREASE
GREASE
GREASE
GREASE
GREASE
GREASE
GREASE
CHECK
6 MO.
OR
1000 HRS
CHANGE
CHANGE
FRONT BOTTOM BEARING PADS GREASE
CHECK
GREASE BOOM SHEAVES (3) FITTINGS
HYDRAULIC SYSTEM
FILTERS
ETHYLENE GLYCOL
ANTI-FREEZE
SAE 15W-40-CD ***
DIESEL FUEL #2
GRADALL HANDLER
SERVICE INSTRUCTIONS
FOR: 534D-9, 534D-10
CONSULT DEALER FOR RECOMMENDATIONS AT EXTREME TEMPERATURES.
*
*
*
*
*
*
*
*
*
*
THIS CHART MUST BE USED IN CONJUNCTION WITH SERVICE MANUAL AND RECOMMENDED PROCEDURE.
CHECK INDICATOR ON HYDRAULIC FILTER. CHANGE FILTER IF NEEDLE IS IN YELLOW
AT FULL THROTTLE & AT OPERATING TEMPERATURE.
CHECK AIR CLEANER RESTRICTION INDICATOR. CLEAN OR CHANGE PRIMARY FILTER IF NECESSARY.
SAFETY ELEMENT TO BE CHANGED EVERY 3RD CHANGE OF PRIMARY FILTER ELEMENT.
IT IS RECOMMENDED THAT FILTER ELEMENTS AND FRONT AXLE LUBRICANT BE CHANGED AFTER
FIRST 50 HRS ON NEW OR REBUILT UNITS.
DAILY SERVICE MAY BE REQUIRED FOR OPTIMUM LIFE DEPENDING UPON APPLICATION SEVERITY.
MOBIL 424
CHECK
CHECK
CHECK
CHECK
CHECK
CHECK
- - - - - - - - - - - - - - - * * - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - -
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
MYSTIK TETRIMOLY
SAMPLE ONLY - USE CHART IN CAB *
* * * *
* * * *
* * * *
* * * *
* * * *