Mountain Off Road BLCJ7679 User Manual
Instructions for m.o.r.e
Thank you for purchasing this M.O.R.E.
™
Body Lift Kit/System. It is designed to fit 1976-1979 Jeep
™
CJ-5,
CJ-7 vehicles with manual or automatic transmissions. It will work with or with out a suspension lift kit. Read
all instructions before starting the installation. Please call if you have any questions.
CONTENTS:
QUANTITY:
DESCRIPTION:
SIZE:
LOCATION: (see figure 1)
11
Aluminum Puck
2-1/4" x I"
All.
10
Hex Head Bolt
3/8" x 3-1/2"
2,3,4,5,6.
1
Hex Head Bolt
7/16" x 3-1/2"
1.
4*
Hex Head Bolt
3/8" x 4"
2,6. *
10
Washer-Flat
3/8"
2,3,4,5,6.
1
Washer-Flat
7/16"
1.
* Locations 2 and 6 may use 3/8" x 4" bolts. Check the length of your stock body bolts to determine which
replacement bolts are to be used for your application.
There are 4 steps to be addressed when installing this body lift kit on your Jeep
™
CJ:
1: The steering shaft and/or column.
2: The radiator/fan shroud.
3: The clutch linkage (or automatic transmission shift linkage).
4: Installing the one inch 0 pucks and longer bolts.
STEP 1: The steering shaft and/or column. Since the body is going to be raised from the frame by one inch
and the column is attached to the body, the shaft that connects the column to the steering box will have to
gain length by approx. 3/8". There are two ways to make this happen:
1A: The shaft is telescoping from the factory (so it can collapse in case of a collision). To make it gain length
or extend the two halves must have the plastic locking device removed. The plastic must be melted out by
heating the shafts. If you choose this method (A), remove the entire shaft from the Jeep
™
. Use a torch and
slightly heat the two halves until the plastic is melted out and the two shafts will slide apart. Do this in a well
ventilated area cause the meeting plastic stinks! Clean them with a wire brush, and paint them. Do not rein-
stall the steering shaft at this time. See figure 2.
BLCJ7679
PAGE 1 of 4
MOUNTAIN OFF ROAD ENTERPRISES,
LLC.
P.O. BOX 690, DELTA, COLORADO 81416
970-625-0500
970-625-3747
Fax
E-mail: [email protected]
www.mountainoffroad.com
INSTRUCTIONS for M.O.R.E.
™
BLCJ7679 1” BODY LIFT KIT