Aries Automotive 15009 - Manual

PARTS LIST:
Qty Description Qty Description
1 Driver/Left Door 2 Rubber Bushing
1 Passenger/right Door 2 Philips Head Sheet Metal Screws
4 8mm Lock Nuts 4 3” x 1” Cylinder Tubes
4 8mm Flat Washers 4 1 3/4" OD x 1/2" Flat Washers
PROCEDURE:
1. REMOVE CONTENTS FROM BOX. VERIFY ALL PARTS ARE PRESENT. READ
INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION.
2. Starting on the Front Passenger side of vehicle remove the (2) factory 50mm Torque bolts
securing the doors onto the hinges, as seen below in (Fig 1). Next begin to remove the mirror from
the inside the vehicle, remove the (2) 40mm Torque bolts holding the mirror onto the door as seen
in (Fig 2) (NOTE :) Hold mirror from the outside so it does not drop & scratch exterior of the door,
once removed place it off to the side, located inside near the lower kick panel remove the dome
light wire harness by pulling the red clip back and unplugging the dome light wire from the harness
seen in (Fig 3) followed by removing the swing out safety strap, seen in (Fig 4). Once removed lift
off the door and place it off to the side.
3. With the factory door removed select your new passenger/right side tubular door slide the door
pins into the factory hinges & secure the doors with (2) 8mm Flat washers & (2) 8mm Lock Nuts as
seen in (Fig 5) Snug the hardware but do not tighten at this time, before closing the door select the
rubber bushing and attach to the inner tube with the Philips head sheet metal screw where the
inner latch is on the door jam, seen in (Fig 6) check the alignment of the locking door latch with the
striker plate inside the door jam of the vehicle seen in (Fig 7) (this may need to be adjusted so that
the door closes completely) if it does need adjustment loosen the toque bolts on the door jam of
the Jeep and align with the door latch on the tubular doors, once in alignment tighten the torque
fasteners check to see that the door completely locks before continuing to the next step.
Page 1 of 3
INSTALLATION INSTRUCTIONS
2007-13 JEEP JK FRONT ALUMINUM TUBULAR DOORS
PART# 15009
Passenger/right side
Front Door
Driver/left side
Front Door