Billy Goat KD505ICQ - Manual (Page 2)

Part No. 890310 Form No. F010396B Page 2 of 8
○ ○ ○
○ ○ ○ ○ ○ ○
○ ○ ○ ○ ○ ○ ○
○ ○ ○ ○ ○ ○ ○ ○ ○
○ ○ ○ ○ ○ ○ ○ ○
○ ○ ○ ○ ○
○ ○
T T T T TABLE OF CONTENTS ABLE OF CONTENTS ABLE OF CONTENTS ABLE OF CONTENTS ABLE OF CONTENTS
6 - 7
8
8
8
5
4
4
3
3
2
OPERATOR
VIBRA VIBRA VIBRA VIBRA VIBRATION TION TION TION TION
SOUND TESTS VIBRATION LEVELS 2.7g
Vibration levels at the operators handles were
measured in the vertical, lateral, and longitudinal
directions using calibrated vibration test equipment.
Tests were performed on 05/03/94 under the conditions
listed:
WIND SPEED:
WIND DIRECTION:
HUMIDITY:
TEMPERATURE:
BAROMETRIC PRESSURE:
GENERAL CONDI-
TION:
SOUND SOUND SOUND SOUND SOUND
Sound tests conducted were in accordance
with 79/113/EEC and were performed on
05/03/94 under the conditions listed:
GENERAL CONDI-
TION:
96
L
A
L
A p
109
Partly Cloudy
29.8" Hg (757mm Hg)
70 %
N.E.
5 MPH (8kmh)
60 F (15.5 C)
WIND SPEED:
WIND DIRECTION:
HUMIDITY:
TEMPERATURE:
BAROMETRIC PRESSURE: 29.8" Hg (757mm Hg)
N.E.
Partly Cloudy
70 %
5 MPH (8kmh)
60 F (15.5 C)
SAFETY INSTRUCTIONS SAFETY INSTRUCTIONS SAFETY INSTRUCTIONS SAFETY INSTRUCTIONS SAFETY INSTRUCTIONS
GENERAL SAFETY
GENERAL SAFETY GENERAL SAFETY GENERAL SAFETY GENERAL SAFETY
ASSEMBL
ASSEMBL ASSEMBL ASSEMBL ASSEMBLY Y Y Y Y
LIT LIT LIT LIT LIT..... B B B B BA A A A AG & CONTR G & CONTR G & CONTR G & CONTR G & CONTROLS OLS OLS OLS OLS
LABELS LABELS LABELS LABELS LABELS
OPERA
OPERA OPERA OPERA OPERATION TION TION TION TION
P P P P PAR AR AR AR ARTS DRA TS DRA TS DRA TS DRA TS DRAWING & LIST WING & LIST WING & LIST WING & LIST WING & LIST
MAINTENANCE MAINTENANCE MAINTENANCE MAINTENANCE MAINTENANCE
TROUBLESHOOTING
TROUBLESHOOTING TROUBLESHOOTING TROUBLESHOOTING TROUBLESHOOTING
W
W W W WARRANTY PR ARRANTY PR ARRANTY PR ARRANTY PR ARRANTY PROCEDURE OCEDURE OCEDURE OCEDURE OCEDURE
6 6 6 6 6
7 7 7 7 7 8 8 8 8 8
THIS SYMBOL MEANS THIS SYMBOL MEANS THIS SYMBOL MEANS THIS SYMBOL MEANS THIS SYMBOL MEANS W W W W WARNING OR CA ARNING OR CA ARNING OR CA ARNING OR CA ARNING OR CAUTION. UTION. UTION. UTION. UTION. DEA DEA DEA DEA DEATH, TH, TH, TH, TH, PERSONAL INJUR PERSONAL INJUR PERSONAL INJUR PERSONAL INJUR PERSONAL INJURY AND/OR PR Y AND/OR PR Y AND/OR PR Y AND/OR PR Y AND/OR PROPER OPER OPER OPER OPERTY TY TY TY TY
D D D D DAMA AMA AMA AMA AMAGE MA GE MA GE MA GE MA GE MAY OCCUR UNLESS INSTR Y OCCUR UNLESS INSTR Y OCCUR UNLESS INSTR Y OCCUR UNLESS INSTR Y OCCUR UNLESS INSTRUCTIONS ARE FOLLO UCTIONS ARE FOLLO UCTIONS ARE FOLLO UCTIONS ARE FOLLO UCTIONS ARE FOLLOWED CAREFULL WED CAREFULL WED CAREFULL WED CAREFULL WED CAREFULLY Y Y Y Y.....
BEFORE ST BEFORE ST BEFORE ST BEFORE ST BEFORE STAR AR AR AR ARTING ENGINE, TING ENGINE, TING ENGINE, TING ENGINE, TING ENGINE, READ AND UNDERST READ AND UNDERST READ AND UNDERST READ AND UNDERST READ AND UNDERSTAND AND AND AND AND THE THE THE THE THE “ENTIRE OPERA “ENTIRE OPERA “ENTIRE OPERA “ENTIRE OPERA “ENTIRE OPERAT T T T TOR'S MANU OR'S MANU OR'S MANU OR'S MANU OR'S MANUAL & EN- AL & EN- AL & EN- AL & EN- AL & EN-
GINE MANU GINE MANU GINE MANU GINE MANU GINE MANUAL. AL. AL. AL. AL.” ”” ””
13. DO NOT DO NOT DO NOT DO NOT DO NOT tamper with governor springs,
governor links or other parts which may
change the governed engine speed.
14. DO NOT DO NOT DO NOT DO NOT DO NOT tamper with the engine speed
selected by the engine manufacturer.
15. DO NOT DO NOT DO NOT DO NOT DO NOT check for spark with spark
plug or spark plug wire removed. Use an
approved tester.
16. DO NOT DO NOT DO NOT DO NOT DO NOT crank engine with spark plug
removed. If engine is flooded, place
throttle in “FAST” position and crank until
engine starts.
17. DO NO DO NO DO NO DO NO DO NOT strike flywheel with a hard
object or metal tool as this may cause
flywheel to shatter in operation. Use
proper tools to service engine.
18. DO NOT DO NOT DO NOT DO NOT DO NOT operate engine without a
muffler. Inspect periodically and replace, if
necessary. If engine is equipped with
muffler deflector, inspect periodically and
replace, if necessary, with correct deflector.
19. DO NOT DO NOT DO NOT DO NOT DO NOT operate engine with an
accumulation of grass, leaves, dirt or other
combustible material in the muffler area.
20. DO NOT DO NOT DO NOT DO NOT DO NOT use this engine on any forest
covered, brush covered, or grass covered
unimproved land unless a spark arrester is
installed on the muffler. The arrester must
be maintained in effective working order by
the operator. In the State of California the
above is required by law (Section 4442 of
the California Public Resources Code).
Other states may have similar laws.
Federal laws apply on federal lands.
21. DO NO DO NO DO NO DO NO DO NOT touch hot muffler, cylinder, or
fins because contact may cause burns.
22. DO NOT DO NOT DO NOT DO NOT DO NOT run engine without air cleaner
or air cleaner cover.
23. DO NOT DO NOT DO NOT DO NOT DO NOT operate during excessive
vibration!
24. DO NOT
DO NOT DO NOT DO NOT DO NOT leave machine unattended
while in operation.
25. DO NOT DO NOT DO NOT DO NOT DO NOT park machine on a steep
grade or slope.
W W W W WARNING: ARNING: ARNING: ARNING: ARNING: DO DO DO DO DO
1. AL AL AL AL ALW W W W WA A A A AYS DO YS DO YS DO YS DO YS DO remove the wire from the
spark plug when servicing the engine or
equipment TO PREVENT ACCIDENTAL
STARTING.
2. DO DO DO DO DO keep cylinder fins and governor
parts free of grass and other debris
which can affect engine speed.
3. DO DO DO DO DO pull starter cord slowly until resis-
tance is felt. Then pull cord rapidly to avoid
kickback and prevent hand or arm injury.
4. DO DO DO DO DO examine muffler periodically to be
sure it is functioning effectively. A worn or
leaking muffler should be repaired or
replaced as necessary.
5. DO DO DO DO DO use fresh gasoline. Stale fuel can
gum carburetor and cause leakage.
6. DO DO DO DO DO check fuel lines and fittings fre-
quently for cracks or leaks. Replace if
necessary
7. Follow Follow Follow Follow Follow engine manufacturer operating
and maintenance instructions.
8. Inspect Inspect Inspect Inspect Inspect machine and work area before
starting unit.
5 5 5 5 5
IN IN IN IN IN THE INTEREST OF SAFETY THE INTEREST OF SAFETY THE INTEREST OF SAFETY THE INTEREST OF SAFETY THE INTEREST OF SAFETY
WARNING:
The Engine Exhaust from this product contains chemicals known
to the State of California to cause cancer, birth defects or other reproductive harm.
W W W W WARNING: ARNING: ARNING: ARNING: ARNING: DO NO DO NO DO NO DO NO DO NOT T T T T
1. DO NOT DO NOT DO NOT DO NOT DO NOT run engine in an enclosed area.
Exhaust gases contain carbon monoxide,
an odorless and deadly poison.
2. DO NOT DO NOT DO NOT DO NOT DO NOT place hands or feet near moving
or rotating parts.
3. DO NOT DO NOT DO NOT DO NOT DO NOT store, spill or use gasoline near
an open flame, or devices such as a stove,
furnace, or water heater which use a pilot
light or devices which can create a spark.
4. DO NOT DO NOT DO NOT DO NOT DO NOT refuel indoors where area is not
well ventilated. Outdoor refueling is
recommended.
5. DO NOT DO NOT DO NOT DO NOT DO NOT fill fuel tank while engine is
running. Allow engine to cool for 2 minutes
before refueling. Store fuel in approved
safety containers.
6. DO NOT DO NOT DO NOT DO NOT DO NOT remove fuel tank cap while
engine is running.
7. DO NOT DO NOT DO NOT DO NOT DO NOT operate engine when smell of
gasoline is present or other explosive
conditions exist.
8. DO NOT DO NOT DO NOT DO NOT DO NOT operate engine if gasoline is
spilled. Move machine away from the spill
and avoid creating any ignition until the
gasoline has evaporated.
9. DO NOT DO NOT DO NOT DO NOT DO NOT transport unit with fuel in tank.
10. DO NOT DO NOT DO NOT DO NOT DO NOT smoke when filling fuel tank.
11. DO NOT DO NOT DO NOT DO NOT DO NOT choke carburetor to stop
engine. Whenever possible, gradually
reduce engine speed before stopping.
12. DO NOT DO NOT DO NOT DO NOT DO NOT run engine at excessive
speeds. This may result in injury
& /or damage to unit.