Multiquip HTX44K4_K5 - Manual (Page 30)

PAGE 30 — HTX-SERIES • RIDE-ON POWER TROWEL — OPERATION MANUAL — REV. #2 (03/21/06)
)
Oil And Fuel Lines
■ Check the oil and fuel lines and connections regularly for
leaks or damage. Repair or replace as necessary.
■ Replace the oil and fuel lines every two years to maintain the
line's performance and flexibility.
Figure 25. Oil Filter
2. Be sure to coat the seal of the new oil filter with clean
engine oil.
Figure 26. Fuel Filter
Oil Filter (100 Hours)
1. Replace the engine oil filter (Figure 25) every oil change
or 100 hours. Refer to your engine manual for specific
details to perform this operation.
Changing Engine Oil And Filter
1. Change the engine oil after the first 5 hours of use, then
change every 6 months or 100 hours.
2. Remove the oil filler cap (Figure 23, Item 6), and fill engine
crankcase with recommended type oil as listed in Table 4.
Fill to the upper limit of dipstick.
3. Crankcase oil capacity with oil filter replacement is 6.72
qts. (7.4 liters).
Fuel Filter (200 Hours)
■ Replace the engine fuel filter element, (Figure 26) every 500
hours. Refer to your engine manual for specific details to
perform this operation.
HTX-SERIES — MAINTENANCE
Oil/Water Separator
Table 4. Recommended Viscosity Grades
F
C
TEMPERATURE RANGE EXPECTED BEFORE NEXT OIL CHANGE
-20 0 20
10W-30, 10W-40
32 40 60 80 100
-30 -20 -10 0 10 20 30 40
5W-20, 5W-30
If the Oil/Water Separator has collected a significant amount of
water at the bottom of the cup it should be drained off. Refer to
your engine manual for specific details to perform this operation.
1
2
3
1. Fuel Filter Bowl
2. Valve Lever (ON position)
3. Valve Lever (OFF position)
4. O-Ring
5. Filter Element
6. Spring
7. Screw Ring
4
5
1
7
6
A
A. Oil Filter Seal