TruXedo Ford F150 Super Crew 2001-2003 - Manual

STEP 2: Install clamp assembly as shown with female clamp
positioned against top of bed rail. Adjust male clamp
as required to level side rail. Tighten clamp assembly.
- Read manual and these special instructions prior to installation.
-Refer to owner’s manual to install your Ford SuperCrew TruXedo
®
kit.
-Follow this instruction sheet to install TruXedo ® side rails on your
Ford SuperCrew.
-Side rails are notched and pre-bent to conform to pickup bed.
L
o
P
rofiLe
T
ru
X
edo
®
side raiL
femaLe
cLamP
Ford SuperCrew Installation Instructions
Tighten clamp assemblies
on side rails before driving
vehicle.
WARNING
maLe
cLamP
PickuP side raiL
w
/
bed caP
side raiL
fLange
STEP 1: Position side rail 1/8” higher than bed cap at front of
pickup box. Attach two clamp assemblies at front of
side rail in pickup box recess on side of pickup box.
PickuP boX
recess
clamp assemblies
T
ru
X
edo ®
side raiL
fLaT washer
,
3/8”
caP screw
,
3/8”
X
1 3/4”
TruXedo, Inc.
P.O. Box 1078, 2209 Kellen Gross Dr., Yankton, South Dakota 57078Call Toll Free: 1-877-TRUXEDO (1-877-878-9336)
Fax: (605) 664-9304 Visit Us Online: http://www.truxedo.com P/N 1114692 Rev. F
NOTE: Images in this instruction contain rails from an Original
TruXedo
®
cover or a Lo Profile
®
cover. Both kit’s rails are installed in
the same way. The difference between the two is shown in step 2.
o
riginaL
T
ru
X
edo ®
side raiL
STEP 3: Attach two clamp assemblies at rear of side rail in recess
of pickup box. Side rail is notched to fit on top of pickup
box post.
pickup-box recess
cLamP assembLies
T
ru
X
edo ®
side raiL
PickuP boX PosT
tailgate
bed caP
corner of side raiL
over bed caP
STEP 4: Mount side rail at tailgate end above bed cap as shown.
Rear header seal functions best when tailgate is closed
and cover is latched on top of tailgate.
Clamp Assembly
1
2
3
4
5
Replacement Parts
1 1703254 Clamp w/Slot, Male
2 1115184 Clamp, Female
3 1115191 Clamp Assembly
4 1700429 Flat Washer, 3/8”
5 1700369 Cap Screw, 3/8” x 1 3/4”
Latch
Assemblies
May Vary
L
o
P
rofiLe
T
ru
X
edo side
raiL shown