Craftsman 580.753000 - Manual (Page 12)

MAINTENANCE
OWNER’S RESPONSIBILITIES
Follow the hourly or calendar intervals, whichever occurs first.
More frequent service is required when operating in adverse conditions noted below.
.......MAINTENANCE SCHEDULE..
F!LL tN DATES AS YOU COMPLETE .......HOURLY OPERATING.........
SERVICE DATES
INTERVAL
MAINTENANCE TASK
Before
::Each:tise:
: Every :5Q ::
Hours Of
Yearly
: Every :1O0: :
Hours or
Yearly
PRESSURE WASHER
:Check/ciean: water Inlet screen.................
X’
; CliecH ihigti ipressure hsse .................. X
: Check :deterfient hose X
: Check spray qon and: assembly for .......
X
• feaks..........................................................
: Purge pump:df:a!r:and: contaminants :::: X
: Change pump oil X
: PreDare pump for storage below 32”F ........ See “S1orage’ on pages 16:............
ENGINE
X
: Check oiS levei
Change engine oil ............................... X- .
: Service: air: cieaner X*
: Service spark :plug X
Service spat1< arrester ........................ X
: Prepare for storage ..........If unit istoremainidlefor.................
::::::::::: longer than 30 daVS- :::::::::::
Clean if clogged. Replace if perforated or tom.
Change oil after the first {5) operating hours and every 50 hours or every year, whichever occurs first, thereafter.
Change sooner when operating under dirty or dusty conditions.
Repiace more often under dirty or dusty conditions.
PRODUCT SPECIFICATIONS
Pressure Washer Specifications
Pressure..................................... 3000 PSI
Flow Rate................................... 2.7 GPM
Chemical Mix..............................Use as directed
Water Supply Temperature........Not to Exceed 100®F
Shipping Weight......................... 75 lbs.
Engine Specifications
Rated Horsepower..................... 7.25 HP
Spark Plug Type:
Long Life Platinum .............. Champion RC12PYP
Resistor................................ Champion RC12YC
Set Gap To:.......................... 0.020 inches
(0.50mm)
Fuel Capacity............................. 3.0 Quarts
Oil
Above 40T ........................... SAE 30
0°F - 40®F ...........................SAE 5W-30 or 10W-30
GENERAL RECOMMENDATIONS
The pressure washer’s warranty does not cover items
that have been subjected to operator abuse or
negligence. To receive full value from the warranty,
the operator must maintain pressure washer as
instructed in this manual including proper storage as
detailed in "Storage” on pages 16-17.
Some adjustments will need to be made periodically to
properly maintain your pressure washer.
All service and adjustments should be made at least
once each season. Follow the requirements in the
“Maintenance Schedule" chart above.
NOTE; Once a year you should clean or replace the
spark plug and replace the air filter. A new spark plug
and clean air filter assure proper fuel-air mixture and
help your engine run better and last longer.
If equipped with inflatable tires, keep the air pressure
at the value marked on the tire or within 16 and 40 psi.
12