Code 3 RockerPak 440L4 or 440L5 - Manual (Page 2)

Rocker Max Pak is a trademark of Code 3, Inc. Code 3 is a registered trademark of Code 3, Inc a subsidiary ofPublic Safety Equipment, Inc.
3M is a registered trademark of 3M Company
PRODUCT RETURNS
In order to provide you with faster service, if you are going to return a product for repair
or replacement*, please contact our factory to obtain a Return Goods Authorization Number
(RGA number) before you ship the product to PSE. Write the RGA number clearly on the
package near the mailing label. Be sure you use sufficient packing materials to avoid
damage to the product being returned while in transit.
*PSE reserves the right to repair or replace product at its discretion. PSE assumes no responsibility or
liability for expenses incurred for the removal and/or reinstallation of products requiring service and/or repair.
WARRANTY
This product was tested and found to be operational at the time of manufacture. Provided this product is
installed and operated in accordance with the manufacturer's recommendations, Code 3, Inc. guarantees all
parts and components except the lamps for a period of 1 year from the date of purchase or delivery, whichever
is later. Units demonstrated to be defective within the warranty period will be repaired or replaced by the factory
or at a factory authorized service center at no cost.
Use of a lamp or other electrical load of a wattage higher than installed or recommended by the factory
causes this warranty to become void. Failure or destruction of the product resulting from abuse or unusual use
and/or accidents is not covered by this warranty.
Code 3, Inc. shall in no way be liable for other damages including consequential, indirect or special
damages whether loss is due to negligence or breach of warranty.
CODE 3, INC. MAKES NO OTHER EXPRESS OR IMPLIED WARRANTY INCLUDING, WITHOUT
LIMITATION, WARRANTIES OF FITNESS OR MERCHANTABILITY, WITH RESPECT TO THIS PRODUCT.
brown purple
red white green yellow orange
blue
Problems or Questions? Call our Technical Assistance HOTLINE - (314) 996-2800
Code 3, Inc.
10986 N. Warson Road
St. Louis, Missouri 63114-2029—USA
www.code3pse.com
relay
1
relay
2
relay
3
1 2 3
relays are 15 amps each
maximum 35 amps
switches are 10 amps each
6 5 4 8
10 GA. Red/Black input 8 GA. Red input
customer supplied fuses
(sized to 125% of
complete load)
panel backlighting
vehicle chassis (earth)
16 GA. black wire
15 Amp Fuses
Battery
(+)12 volt ignition circuit
white/black wire
maximum 30 amps
40 Amp circuit breaker
40 Amp circuit breaker
7
Revision 1, 02/2006 - Instruction Book Part N0. T04920
©1995-2006 Code 3, Inc. Printed in USA