Allen Sports 303S - Manual

M M M Mo o o od d d de e e ellll 3 3 3 30 0 0 03 3 3 3S S S S IIIIn n n ns s s sttttrrrru u u uc c c cttttiiiio o o on n n ns s s s
English - Page 1 V.12.2
W W W W ARNING ARNING ARNING ARNING : : : : B B B B IKES IKES IKES IKES OR OR OR OR RACK RACK RACK RACK FALLING FALLING FALLING FALLING IN IN IN IN ROAD ROAD ROAD ROAD CAN CAN CAN CAN CAUSE CAUSE CAUSE CAUSE SERIOUS SERIOUS SERIOUS SERIOUS ACCIDENTS ACCIDENTS ACCIDENTS ACCIDENTS RESULTING RESULTING RESULTING RESULTING IN IN IN IN BODILY BODILY BODILY BODILY INJURY INJURY INJURY INJURY — — — — DO DO DO DO NOT NOT NOT NOT USE USE USE USE RACK RACK RACK RACK ON ON ON ON
ANY ANY ANY ANY VEHICLE VEHICLE VEHICLE VEHICLE ON ON ON ON WHICH WHICH WHICH WHICH IT IT IT IT CAN CAN CAN CAN NOT NOT NOT NOT BE BE BE BE PROPERLY PROPERLY PROPERLY PROPERLY MOUNTED MOUNTED MOUNTED MOUNTED AS AS AS AS DESCRIBED DESCRIBED DESCRIBED DESCRIBED IN IN IN IN THIS THIS THIS THIS INSTRUCTION INSTRUCTION INSTRUCTION INSTRUCTION SHEET SHEET SHEET SHEET ....
• Use this rack only on rear mounted external spare tires. Make sure that spare tire is securely attached and that the
tire is fully inflated.
• Never use rack on spare tires mounted on any type of trailer, RV, or on the front of vehicle.
• Never carry more than 3 bicycles ( MAX MAX MAX MAX CAPACITY CAPACITY CAPACITY CAPACITY : 100 LB : 100 LB : 100 LB : 100 LB) - no tandems, mopeds, or recumbents. Car tail lights
must remain visible. Bikes must be securely tied to rack. Use bike tie-downs, or additional straps if necessary.
• Drive conservatively, especially over bumps. Never use off-road.
• Do not use if any part of the rack is damaged, worn, or missing. Contact R. A. Allen Co., Inc. for replacement parts.
C C C C AUTION AUTION AUTION AUTION : : : : Use Allen 303S only in accordance with local motor vehi-
cle and traffic regulations.
• To avoid damage to rear door or trunk, do not open trunk or
rear door when hooks or rack are in place.
• Install rack and load bicycles only at a safe distance away
from moving traffic.
• Only rubber feet and rack should come into contact with car.
• Make sure that all of rack and bicycles are kept at a safe dis-
tance from road and hot exhaust.
• Remove rack from car when not in use
A. A. A. A. S S S S ETTING ETTING ETTING ETTING UP UP UP UP R R R R ACK ACK ACK ACK :::: B. B. B. B. IIII NSTALLING NSTALLING NSTALLING NSTALLING R R R R ACK ACK ACK ACK ON ON ON ON V V V V EHICLE EHICLE EHICLE EHICLE ::::
1. O NLY USE RACK ON REAR MOUNTED EXTERNAL SPARE TIRES INSTALLED ON STANDARD AUTOMOBILES AND
TRUCKS . NEVER NEVER NEVER NEVER USE RACK ON TRAILERS OR RV’ S . M AKE SURE THAT SPARE TIRE IS SECURELY AT-
TACHED AND FULLY INFLATED .
2. B
EFORE INSTALLING , REMOVE ANY
SPARE TIRE COVERS THAT MAY BE
DAMAGED BY RACK .
3. C OMPLETELY HOOK TOP FOOT /
CARRY ARM ASSEMBLY [A] [A] [A] [A] OVER
THE TOP OF SPARE TIRE . P OSITION
RACK WITH CARRY ARMS INCLINED
SLIGHTLY UPWARDS AND HIGH
ENOUGH TO KEEP TAIL LIGHTS VISI-
BLE
4. B
OTTOM FOOT ASSEMBLY [B] [B] [B] [B] MUST
BE HELD AGAINST THE TIRE IN A
FULLY EXTENDED POSITION .
5. C
OMPLETELY HOOK BOTTOM HOOKS
TO A METAL EDGE BELOW BUMPER ,
OR AT THE BOTTOM OF THE REAR
DOOR .
6. O
PENING REAR DOOR SLIGHTLY CAN
MAKE IT EASIER TO ATTACH BOTTOM
HOOKS .
7. I
F THERE IS NO METAL EDGE AT THE
BOTTOM OF REAR DOOR , LOOK FOR
A METAL EDGE BELOW THE BUMPER .
A LTERNATIVELY , THE STRAPS CAN
BE LOOPED AROUND BAR STYLE
BUMPERS .
7. C
OMPLETELY TIGHTEN BOTTOM
STRAPS BY PULLING ON FREE END OF STRAPS UNTIL ELASTIC PORTION OF STRAPS ARE COMPLETELY
STRETCHED .
1. F OLD OUT TOP FOOT / CARRY ARM
ASSEMBLY [A] [A] [A] [A]
2. S ET -U P PINS
WILL “S NAP ”
INTO PLACE .
3. C OMPLETELY FOLD OUT
B OTTOM F OOT A SSEMBLY [B] [B] [B] [B]
[A] [A] [A] [A]
[B] [B] [B] [B]