Pro-Link BreakThru B14193 - Manual

FOR-0181 MATERIAL SAFETY DATA SHEET
N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 4/09 Revision: 3/12
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Force
Generic Name: Non-Acid Drain Opener
Chemical Family: Alkaline Detergent Blend
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Sodium Hydroxide 1310-73-2 10 to 15 N/A C2mg/M 3 N/A
Sodium Hypochlorite 7681-52-9 0 to 5
Anionic Surfactant N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 211 F. Specific Gravity: 1.147
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 75+ pH: 13.5-14.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin clear liquid with characteristic odor.
Flash Point (Method Used): None
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids. Aluminum contact may release
hydrogen gases
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER: CORROSIVE. Will cause permanent eye damage and irreversible skin damage. Avoid contact with eyes, skin and clothing. Wear rubber gloves and eye protection when
handling. Wash hands immediately after use. Keep out of reach of children. For use by trained personnel only. Keep container tightly closed during storage. For institutional and
industrial use only. Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible skin
damage.
Eyes: Severe eye irritant. Liquid and mists will damage eyes, causing corneal damage.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose,
throat, and lungs.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, nausea,
abdominal pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 ingredients
below acceptable limit.
Protective Gloves: Chemical resistant rubber, alkaline resistant.
Eye Protection: Safety glasses or full-face shield recommended.
Other Protective Equipment: Eye wash. Protective clothing should be worn when
handling.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention
if irritation persists.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. For large spills, avoid discharge to sewer or open
waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Best method is to recycle or reuse for intended purpose. If discarded, this material and
containers should be treated as hazardous waste based on the characteristic of corrosivity
as defined under federal RCRA regulations (40 CFR 261). Consult local authorities for
disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Sodium Hydroxide), 8, NA-1760, PG III Health 3
Yes - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 1
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound LQ Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Break Thru Drain Cleaner