Pro-Link Clinging Bowl Cleaner B14154 - Manual

BOB MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 4/05 Revision: 3/12
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: Bowl Bryte
Generic Name: Low Acid Bowl Cleaner
Chemical Family: Acid Detergent Blend
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Hydrochloric Acid 7647-01-0 5 to 10 C5 ppm C5 ppm N/A
Dimethyl Benzyl Ammonium Chloride 68424-85-1 0 to 5
Nonionic Surfactant 9016-45-9 0 to 5
Acrylic Latex N/A 0 to 5
Perfume Oils N/A 0 to 5
Dye N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point ( ° F): 214 F. Specific Gravity: 1.041
Vapor Pressure: 25mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 0.5-1.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin blue opaque liquid with pleasant odor.
Flash Point (Method Used): N/A
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Hydrogen or chlorine gas. Incompatibility (Materials to Avoid): Strong alkalis or oxidizers. Contact with
aluminum, soft metals and iron may generate hydrogen gas.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER Keep out of reach of children. For use by trained personnel only. Do not mix with alkali cleaners, oxidizers or other cleaning products. Keep container closed during storage.
For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear rubber gloves and protective eyewear when handling. Wash hands after each use. Avoid
breathing of vapors. Use in well-ventilated area only. Avoid contact with aluminum, brass, iron.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Skin irritant. Prolonged or repeated contact may cause chemical burns.
Eyes: Severe eye irritant. Liquid and mists may burn or injure eyes, causing corneal
damage.
Inhalation: Irritating to mucous membranes of the nose, throat, and lungs. Vapors may
cause choking, burning sensation of throat and lungs, leading to irreversible damage.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, nausea,
abdominal pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2
ingredients below acceptable limit.
Protective Gloves: Acid proof, rubber, or neoprene.
Eye Protection: Safety glasses or chemical splash goggles.
Other Protective Equipment: Eyewash, chemical resistant apron.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Remove contaminated clothing. Flush exposed area with large quantities of water
followed by washing with mild soap. Seek medical attention if irritation persists.
Eyes: Immediately flush with large quantities of water, holding eyelids open. Seek
medical attention immediately.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become slippery.
Avoid walking in product. Keep unessential personnel away. Mop up or otherwise
absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Best method is to recycle or reuse for intended purpose. Consult local authorities for
disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (hydrochloric acid), 8, NA-1760, PG III Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: Cleaning Compound LQ Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and of
40 CFR 372.
CAS# Chemical Name Percent by Weight
Exempt None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Clinging Bowl Cleaner