Pro-Link Extra Duty Bowl Cleaner B14097 - Manual

BRU MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 10/08 Revision: 5/12
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Supplier Name:
Misco Products Corporation
Supplier’s Address:
1048 Stinson Drive Reading, PA 19605
Supplier’s Phone #: (610) 926-4106
Product Name: Brute
Generic Name: High Acid Emulsion Bowl Cleaner
Chemical Family: Hydrochloric Acid/Detergent Blend
Formula: Proprietary
Distributor’s Name:
Distributor’s Address:
Distributor’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Hydrochloric Acid 7647-01-0 24 min 5 ppm 5 ppm N/A
Lauramine Oxide 1643-20-5 0 to 5
Benzalkonium Chloride 68424-85-1 0 to 5
Alcohols, C12-C15, Ethoxylated 68131-39-5 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 205 F. Specific Gravity: 1.175
Vapor Pressure: 33mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 0.5-1.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin white opaque liquid with characteristic pungent odor.
Flash Point (Method Used): N/A
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Hydrogen gas formed on contact with metals. HCL
vapors emitted when heated. Chlorine gas may form by electrolysis or oxidation.
Incompatibility (Materials to Avoid): Corrosive to many materials. Strong alkalis or
oxidizers, bleaching agents, amines and carbonates. Contact with metals, metal oxides,
soft metals and iron may generate hydrogen gas.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER! POISON. ACID Corrosive. Causes chemical burns to eyes and skin. Harmful if inhaled. Harmful if swallowed. Avoid contact with eyes, skin and clothing. Avoid
breathing of vapors. Wear rubber gloves and protective eyewear when handling. Keep out of reach of children. For use by trained personnel only. Do not mix with alkali cleaners,
oxidizers or other cleaning products. Keep container closed during storage. For institutional and industrial use only. Wash hands after each use. Use in well-ventilated area only.
Avoid contact with aluminum, brass, iron and strong alkaline cleaners or bleaches
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. Prolonged or repeated contact will cause permanent chemical
burns.
Eyes: Severe eye irritant. Liquid and mists will burn or injure eyes, causing permanent
corneal damage.
Inhalation: Strong irritant to mucous membranes of the nose, throat, and lungs. Vapors
may cause choking, burning sensation of throat and lungs, leading to irreversible
damage. May be fatal. Chronic exposure may damage teeth.
Ingestion: POISON Irritating and corrosive to the mouth and throat on immediate
contact. May be fatal. Cause severe ulceration of mucous membranes.
Respiratory Protection: NIOSH approved acid-gas air purifying canister when used in
confines or poorly ventilated areas
Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2
ingredient (Hydrochloric Acid) below acceptable limit.
Protective Gloves: Full arm length acid proof, rubber, or neoprene.
Eye Protection: Chemical splash goggles or full-face safety shield.
Other Protective Equipment: Eyewash station should be made available near site
where used. Chemical resistant apron should be worn when danger of splash contact
will occur.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Immediately remove contaminated clothing. Flush exposed area with large
quantities of water followed by washing with mild soap. Seek medical attention
immediately.
Eyes: Immediately flush with large quantities of water for at least 15 minutes, holding
eyelids open. Seek medical attention immediately.
Inhalation: Get to fresh air. Seek medical attention immediately.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Immediately evacuate all
unessential personnel from area. Ventilate area well. Acquire special protection
equipment as noted in Section 8. Absorb spill with inert material. Neutralize with soda
ash or lime. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Best method is to recycle or reuse for intended purpose. If disposed of in its purchased
form, this product has the RCRA characteristic of corrosivity and would have an EPA
Hazardous waste number of D002. Consult local authorities for disposal in public sewer.
Do not dispose of into storm drain, stream, river or to ground. Rinse container
thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Liter: UN1760, Corrosive liquids, n.o.s. Identification System
No - Sudden Release of Pressure Hazard (contains Hydrochloric Acid), 8, PG II Health 3
No - Reactivity Hazard FOR CONTAINERS ≤ 1 Liter: LTD QTY Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard Personal Protection C
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
Exempt None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information 5/14/12-Revised Sec 10 Shipping under 1 gal. descriptor. Changed ingredient info. in Sec. 2; Descrip. in Sec.
3 changed.
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
Extra Duty Bowl Cleaner