Pro-Link 1-2-20 B14102 - Manual

OPU MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200) Effective Date: 8/08 Revision: 3/12
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s Name:
Misco Products Corporation
Manufacturer’s Address:
1048 Stinson Drive Reading, PA 19605
Manufacturer’s Phone #: (610) 926-4106
Product Name: One Pass
Generic Name: Ultra Concentrated Speed Stripper
Chemical Family: Solvent Detergent Blend
Formula: Proprietary
Supplier’s Name:
Supplier’s Address:
Supplier’s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 15 to 20 50 ppm 25 ppm N/A
Monoethanolamine 141-43-5 20 to 25 N/A 8mg/M 3 6 ppm
Benzyl Alcohol 100-51-6 50 to 55 N/A 3 ppm 6 ppm
Nonionic Surfactant 9016-45-9 0 to 5
Fluorochemical Dispersion N/A 0 to 5
Perfume Oils N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 212 F. Specific Gravity: 1.012
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
% Volatile: 90+ pH: 11.0 – 12.0
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Physical Description: Thin liquid with characteristic odor.
Flash Point (Method Used): >200˚ F. (TCC)
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Extinguishing Media: Foam, water fog, CO
2
or dry chemical.
Special Firefighting Procedures: Wear self-contained breathing apparatus
for confined areas. Keep fire exposed containers cool with water spray.
Unusual Fire and Explosion Hazards: Vapors heavier than air.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids, Oxidizers.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER Corrosive Liquid. Severe Eye and/or skin damage will result with contact. Avoid contact with eyes, skin and clothing. Wear protective eyewear, gloves and
footwear when handling. Avoid breathing of vapors. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when
applying to floor. Keep container closed during storage. For institutional and industrial use only. Use in well-ventilated area only. Avoid contact with heat, spark or
open flame.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure:
Skin: Severe skin irritant. May cause moderate reddening, swelling, blistering, and
possible skin damage.
Eyes: Severe eye irritant. Liquid and mists will damage eyes, causing corneal
damage and blindness.
Inhalation: Vapors and mists are irritating to mucous membranes in the nose,
throat, and lungs; characterized by coughing, choking, shortness of breath.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache,
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
Respiratory Protection: Use NIOSH approved organic vapor respirator or self-
contained breathing apparatus in confined or poorly ventilated areas.
Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section 2
ingredients below acceptable limits.
Protective Gloves: Chemical resistant rubber or neoprene.
Eye Protection: Chemical splash goggles or full-face shield.
Other Protective Equipment: Eye wash station nearby. Protective outerwear and
rubber boots should be worn when using.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Immediately flush with water. Remove contaminated clothing and shoes.
Seek medical attention immediately.
Eyes: Contact damage is immediate. Immediately flush with large quantities of
water, holding eyelids open. Seek medical attention immediately.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
Steps to be taken in Case Material is Released or Spilled: Floors will become slippery.
Avoid walking in product. Keep unessential personnel away. Mop up or otherwise absorb
and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws. Best
method is to recycle or reuse for intended purpose. If discarded, this material and containers
should be treated as hazardous waste based on the characteristic of corrosivity as defined
under federal RCRA regulations (40 CFR 261).Consult local authorities for disposal in public
sewer. Do not dispose of into storm drain, stream, river or to ground. Rinse container
thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Monoethanolamine Solution), 8, NA-1760, PG III Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound LQ Flammability 1
Yes - Immediate (acute) Health Hazard Reactivity 0
Yes - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound LQ Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 2-butoxyethanol (Glycol Ether) N-230 15%
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
REVISION: 3/16/12- Revised Sec. 10 Shipping Information
Pro-Link, Inc.
Canton, MA 02021
1-800-74-LINKS
1-2-20