Pro-Link #1 ChemiCenter Link 2000 SC Glass Cleaner 07083 - Manual

#1 Link 2000 SC
NFPA/HMIS : Health - 2, Flammability - 2, Reactivity - 0
Complies With USDL Safety and Health Regulations, (29 CFR 1910.200)
Material Safety Data Sheet US Department Of Labor
SECTION - 1 CHEMICAL AND COMPANY IDENTIFICATION
PRODUCT NAME: #1 LINK 2000 SC
PRODUCT USE: Window cleaner concentrate
PRO-LINK
510 Chapman Street, Canton, MA 02021
EMERGENCIES: 1-800-255-3924
REVISION DATE: 06/01/00
SECTION - 2 COMPOSITION ON INGREDIENTS
CAS # CHEMICAL NAMES Wt% TLV (UNITS)
111-76-2 Ethylene Glycol Monobutyl Ether < 50 25 (PPM) skin
67-63-0 Isopropanol < 10 400(PPM) TWA
107-98-2 Propylene Glycol Monomethyl Ether <10
SECTION - 3 HAZARDS INFORMATION
Primary Route(s) of Entry : Skin contact /absorption and inhalation
Signs and Symptoms of Overexposure: Gastrointestinal irritation (nausea, vomiting,
diarrhea), irritation to nose, throat, and respiratory tract.
Target Organ Effects: Overexposure to this material (or its components) has been
suggested as a cause of the following effects in laboratory animals and may aggravate
pre-existing disorders or these organs in humans: chronic ingestion may cause kidney
and liver lesions at high doses.
IMMEDIATE HEALTH EFFECTS:
EYES: Exposure may cause noticeable pain, and severe irritation and transient corneal
injury.
SKIN: Exposure may cause mild skin irritation. Prolonged or repeated exposure may
dry the skin. Symptoms may include redness, burning, drying and cracking and skin
burns. Additional symptoms of skin contact may include allergic reaction. Skin
absorption is possible, but harmful effects are not expected from this route of exposure
under normal handling and use.
INHALATION: Exposure to vapor or mist is possible. Short-term inhalation is not likely
to cause harmful effects: breathing large amounts may be harmful. Symptoms are more
typically seen at air concentrations exceeding the recommended exposure limits.
INGESTION: Single dose oral toxicity is low. Swallowing small amounts during normal
handling is not likely to cause harmful effects. Swallowing large amounts may be
harmful.
REPRODUCTIVE / DEVELOPMENTAL INFORMATION: No Data
CARCINOGENIC INFORMATION: IARC, NTP, or OSHA does not list this material as a
carcinogen
LONG TERM EFFECTS: No Data
SECTION - 4 FIRST AID MEASURES
EYES- Flush eyes with clear water for 15 minutes. Get prompt medical attention.
SKIN- Rinse with water for 15 minutes. If irritation develops, get medical attention.
INHALATION- If symptoms develop move victim to fresh air. If symptoms persist, call a
physician.
INGESTION- Immediately give 1 or 2 glasses of water and induce vomiting by sticking
finger down throat. Keep victim's head below waist to prevent aspiration into lungs. Get
prompt medical attention.
SECTION - 5 FIRE FIGHTING MEASURES
Flash Point: 107 degrees Fahrenheit (C.C. method)
Explosive limits: Unknown
Autoignition Temperature Unknown
Hazardous Products of Combustion
Carbon Dioxide Carbon Monoxide
Fire Fighting Instructions
Avoid contact with this material. Avoid walking in spilled material. Wear protective
clothing for skin and eyes
Extinguishing Media Not Applicable
SECTION - 6 ACCIDENTAL RELEASE MEASURES
Small Spill: Absorb with an inert solid and scoop up for disposal, then rinse soiled area
with water down the drain.
Large Spill: S top leak at the source and collect into a suitable container, then treat as
a small spill.
SECTION - 7 HANDLING AND STORAGE
Handling: Containers of this material may be hazardous when emptied. Since emptied
containers retain product residues (vapor, liquid, and/or solid), all hazard precautions
given in the data sheet must be observed.
Storage: Store in a cool, dry place. Keep container closed when not in use.
SECTION - 8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Chemical Splash goggle in compliance with OSHA regulations are
advised: however, OSHA regulations also permit other type safety glasses. Consult
your safety representative.
Skin Protection: Wear rubber gloves (consult your safety equipment supplier). To
prevent repeated or prolonged skin contact, wear impervious clothing and boots.
Respiratory Protection: If workplace exposure limits of product or any component are
exceeded (see exposure guidelines), NIOSH/OSHA approved air supplied respirator is
advised in the absence of proper environmental control. OSHA relations also permit
other NIOSH/OSHA respirators (negative pressure type) under specific conditions (see
your industrial hygienist). Engineering or administrative controls should be implemented
to reduce exposure.
Engineering Controls: Provide sufficient mechanical (general and local exhaust)
ventilation to maintain exposure below level of overexposure (from known, suspected or
apparent adverse effects).
SECTION - 9 PHYSICAL AND CHEMICAL PROPERTIES
Appearance and odor: Thin, blue liquid with an alcohol odor
pH Concentrate: 10.5 - 11.5
Vapor Pressure: Unknown Vapor Density: Unknown
Boiling Point: 209 Degrees Fahrenheit
Solubility in Water: Complete Percent
Volatile: 95%
Specific Gravity: (H
2
O =1) .90 +/- 0.02
SECTION - 10 STABILITY AND REACTIVITY
Chemical Stability: Stable Conditions to Avoid: Temperature Extremes
Incompatibility: None Hazardous Decomposition: None
Hazardous Polymerization: Will not occur
SECTION - 11 TOXICOLOGICAL INFORMATION
No Data Available
SECTION - 12 ECOLOGICAL INFORMATION
No Data Available
SECTION - 13 DISPOSAL CONSIDERATION
Waste Disposal Information: Dispose of in accordance with all applicable Federal,
State, and Local regulations.
RCRA Information: If this material becomes a waste, it would not be considered
hazardous under 40 CFR 261.22.
SECTION - 14 TRANSPORT INFORMATION
DOT Information 49 CFR 172.101
DOT Description:
33440 Class 55
DOT Hazard Class: Class 3 UN1219, II
Hazardous Component: Isopropanol
Reportable Quantity (RQ) - 49 CFR 172.101: Not Applicable
SECTION - 15 REGULATORY INFORMATION
US Federal Regulations
TSCA (Toxic Substances Control Act) Status
TSCA (United States) The intentional ingredients of this product are listed.
CERCLA RQ - 40 CFR 355 Appendix A: None
SARA 302 Components 40 CFR Appendix A: None
Section 311/312 Hazard Class 40 CFR 370.2
Immediate (X) Delayed (X) Fire ( ) Reactivity ( ) Sudden Release of Pressure ( )
SARA 313 Components - 40 CFR 372.65
CAS #
Chemical Names %
N/A * Glycol Ethers < 50
* Listed in Section 2 as Ethylene Glycol Monobutyl Ether
State and Local Regulations
California Proposition 65:
None
California SCAQMD Rule 443.1VOC’s: > 800g/L
North Carolina Administrative Code 2D.1104 and 2B.0610: None
South Carolina Regulation 62.5 Standard Number 8:
Ethylene Glycol Monobutyl Ether <50
SECTION - 16 OTHER INFORMATION
The information accumulated herein is believed to be accurate but is not warranted to
be whether originating with the company or not. Recipients are advised to confirm in
advance of need that the information is current, applicable and suitable to their
circumstances.
This information was compiled from current manufacturer’s MSDS’s of the component
parts of the product. as well as other sources, such as:
Code of Federal Regulations 29, Revised as of July 1. 1994.
Code of Federal Regulations 40, Revised as of July 1, 1994.
ACGIH, Guide to Occupational Exposure Values, 1996.
ANSI Z129.1-1994, Precautionary Labeling for Hazardous Industrial Chemicals.
Hazard Communication Handbook, A Right To Know Compliance Guide. Craig A.
Moyer & Michael Francis. Clark Broadman Company. Ltd. New York, NY 1992
RCRA Regulations and Keyword Index, Compiled and Published by McCoy and
Associates, Inc Lakewood, Colorado. 1992.