Checkline MX-1 - Manual (Page 31)

MATERIAL SAFETY DATA SHEET
N/A = not applicable or not available (To comply with 29 CFR 1910.1200)
SECTION 1 – PRODUCT IDENTIFICATION
Product Name: SOUNDSAFE

Generic Name: Ultrasonic Couplant
Manufacturer: Sonotech, Inc.
774 Marine Dr., Bellingham, WA 98225
(360) 671-9121
NFPA Hazardous Materials
Identification System (est)
Health……………………0
Flammability…………….0
Reactivity………………..0
SECTION 2 – HAZARDOUS INGREDIENTS
This material does not contain any ingredients having
known health hazards in concentrations greater than 1%.
This material does not contain any known or suspected
carcinogens.
SECTION 3 – PHYSICAL DATA
(nominal)
Boiling Point: >220
°
F pH: 7.35 – 7.9
Freezing Point: <20
°
F Acoustic Imp.: 1.726x10
6
Vapor Pressure: N/A Vapor Density: N/A
Evaporation Rate: N/A Specific Gravity: >1.02
Solubility in Water: complete
Appearance and Odor: water white, opaque gel;
bland odor
SECTION 4 – FIRE AND EXPLOSION
HAZARD DATA
Flash Point: none
Upper Exposure Limit: none
Lower Exposure Limit: none
Special Fire Fighting Procedures: N/A
Extinguishing media: N/A
Unusual Fire and Explosion Hazards: none
SECTION 5 – REACTIVITY DATA
Stability: Stable
Conditions to Avoid: none
Incompatibility (Materials to Avoid): none known
Hazardous Polymerization: will not occur
Hazardous Decomposition or Byproducts: none known
SECTION 6 – HEALTH HAZARD AND FIRST AID DATA
Routes of Entry:
1
Skin: not likely Ingestion: not normally
Eyes: not normally Inhalation: no
Effects of Overexposure: Acute: May cause temporary
eye irritation
Chronic: none expected
First Aid Procedures:
Skin: Remove with water if desired.
Eyes: Flush with water for 15 minutes.
Ingestion: For large quantities, induce vomiting and
call a physician.
Inhalation: N/A
SECTION 7 – STORAGE AND HANDLING
INFORMATION
Precautions to be taken in handling and storage: Store
between 20
°
F and 120
°
F. Spills are slippery and should
be cleaned up immediately.
Steps to be taken in case material is released or spilled:
Pick up excess for disposal. Clean with water.
Waste disposal method: Dispose of in accordance with
federal, state, and local regulations.
SECTION 8 – CONTROL MEASURES
Respiratory Protection: not required
Ventilation: not required
Protective Gloves: on individuals demonstrating
sensitivity to SOUNDSAFE

Eye Protection: as required by working conditions
Other Protective Equipment: not required
1
SOUNDSAFE

contains only food grade and cosmetic grade ingredients.
Toll Free: 1-800-458-4254
SONOTECH, INC.
774 Marine Dr., Bellingham, WA 98225
Telephone: (360) 671-9121 Fax: (360) 671-9024