Behlen 80111330YEL - Manual (Page 3)

F-20866 2 1-17-11
• Do not modify the implement in any way.
Unauthorized modifications could result in
serious injury or death and may impair the
function and shorten the life of the equipment
and void any warranty coverage.
• In addition to the design of this implement,
including safety decals and safety equipment,
accident prevention is dependent upon the
awareness, common sense, forethought, and
proper training of everyone involved in the
operation, transport, maintenance, and storage
of the machine. Also refer to safety messages
and operating instructions in each of the
appropriate sections of the tractor manual. Pay
close attention to the safety decals affixed to
both the tractor and Disc Harrow.
• The Disc Harrow is designed for speeds of 5
mph or less. Reduce speed on rough surfaces.
Speeds beyond those recommended may
cause damage to the implement and void the
warranty.
• Never place hands or feet under Disc Harrow.
Stay clear of all moving parts.
• Do not reach or place any part of your body
under the equipment until it is blocked securely.
• Never allow riders on the Disc Harrow or tractor
at any time. There is no safe place for riders.
• DISC BLADES ARE SHARP! BE CAREFUL!
Avoid situations where discs may accidentally
roll over or fall on any part of your body. Be
especially careful working with wrenches which
may slip near sharp blade edges.
• Worn edges can seriously affect the Disc
Harrow’s penetration. Check for wear before
each use and sharpen or replace if necessary.
PREPARATION
• Never operate the tractor and Disc Harrow until
you have read and completely understand this
manual, the Tractor Operator’s Manual, and any
messages found on the safety decals on the
tractor and Disc Harrow.
• Do not wear loose fitting clothing or jewelry and
be sure to contain long hair around equipment.
• Always wear your seat belt. Serious injury
or even death could result from falling off the
tractor - particularly during a rollover when the
operator could be trapped under the ROPS or
the tractor.
• Ensure Disc Harrow is properly mounted,
adjusted and in good operating condition.
• Ensure that all safety guards and safety decals
are properly installed and in good condition.
• Do not operate unless all personnel, livestock,
and pets are several hundred feet away to
prevent injury by thrown objects. Never direct
the discharge chute toward anyone.
• Never operate tractor and Disc Harrow under
trees with low hanging limbs. Operators can be
knocked off the tractor and then run over by the
rotating blades.
• Stop Disc Harrow and tractor immediately upon
striking an obstruction. Turn engine off, remove
key, then inspect and repair any damage before
resuming operation.
• Stay alert for uneven terrain, holes, rocks
roots and other hidden hazards. Keep away
from drop-offs and hazards that could cause
a rollover. Use extreme care and maintain
minimum ground speed when transporting or
operating on hillsides, over rough ground and
when operating close to ditches or fences. Be
careful and slow down when turning sharp
corners and changing direction on slopes.
Do not start or stop suddenly on slopes and
avoid operating on steep slopes. In extremely
uneven terrain, rear wheels weights, front
tractor weights, and/or tire ballast should be
used to improve stability.
• Drive Disc Harrow diagonally over sharp dips
and avoid sharp drops to prevent tractor and
Disc Harrow from “hanging up”. Always move
downward on slopes, never cut across the
face. Always check tractor manual for proper
use on slopes. Practice will improve your skills
in maneuvering on rough terrain.
• A minimum of 20% of the tractor and
equipment weight must be on the tractor’s front
wheels. Without this weight, the tractor could
tip over, causing personal injury or death. The
weight may be attained with a front-end loader,
front wheel weights, ballast in the tires or front
tractor weights. When attaining a minimum
20% of the tractor and equipment weight on the