Crown Equipment RR 5200S Series - Manual (Page 9)

Display Panel
with options
16
Display Panel
with options
FORKS DOWN LIGHT (see Caution)
The green light means the mast is at its minimum collapsed
height. Make certain the load and load backrest will also
clear any overhead obstructions.
CAPACITY DATA MONITOR (see Caution)
• Fork height lights: A yellow fork will light to show
which lift zone the forks are in. If any of these lights are
on, it means the load backrest is higher than the collapsed
height of the mast. Make certain the load and load backrest
will clear any obstructions above you.
The yellow light will flash and alarm will "beep" if you
travel faster than the load positioning speed (2.4 kmph,
1.5 MPH) while the load backrest is above the collapsed
height of the mast.
• Fork height lights: The green bars will light to show
how high, or to which lift zone you can raise a load.
• Overload warning: If the load is too heavy for the lift
zone the forks are in, the alarm will "beep" and the message
display will read .
EXPANDED MESSAGE DISPLAY
See page 17 for typical messages.
ADDITIONAL SERVICE BUTTONS
See your Service Manual for
instructions.
Caution: All information displayed by the fork position lights and/or the Capacity Data
Monitor is for reference only. You must always be alert to load center, load distribution,
load height and load weight. You must also be aware when the load or load backrest
extends above the top of the mast, and how much overhead clearance is needed.
CHECK LOAD
Display Panel
standard
15 Display Panel
standard
WRENCH LIGHT
A yellow light means something needs to be fixed. Report
the trouble to your supervisor.
STANDARD MESSAGE DISPLAY
See page 17 for typical messages.
ERROR LIGHT
A yellow light means you have tried to perform an operation
that is not permitted. Check the message display.
BATTERY CHARGE DISPLAY
The green bars show how much charge is left. Have the
battery changed or recharged if the yellow light is flashing.
FORK HEIGHT LIGHT (see Caution)
A yellow light means the load backrest is higher than the
collapsed height of the mast. Make certain the load and
load backrest will clear any obstructions above you.
The yellow light will flash and alarm will "beep" if you
travel faster than the load positioning speed (2.4 kmph,
1.5 MPH) while the load backrest is above the collapsed
height of the mast.
SERVICE AND OPTION BUTTONS
See your Service Manual for
instructions.