Char-Broil 5101194 - Manual (Page 7)

WARNING
Ignitor Lighting
1. Open lid during lighting.
2. Press and turn the control knob to the
position.
3. Turn knob rapidly.
4. If ignition does not occur in 5 seconds, turn the burner
control knob , wait 5 minutes, and repeat lighting
procedure. If ignition still does not occur, follow
instructions.
HI
ROTARY IGNITOR
OFF
“Match
Lighting”
CAUTION
If burner does not light turn knob to OFF, wait 5
minutes, try again. If the burner does not ignite with
valve open, gas will continue to flow out of the burner
and could accidentally ignite with risk of injury.
Match Lighting
Burner Flame Check
Burner Check
Turning Appliance Off
Ignitor Check
Valve Check
Hose Check
Do not lean over appliance while lighting. Use a large
kitchen match or fireplace match to light the
appliance.
1.
2.
HI
HI LOW
LOW
HI
OFF OFF
OFF
OFF
OFF
MED
OFF
Place a lit match to burner.
Press and turn control knob
To
.
• Light burner, rotate knob
from to . You
should see a smaller
flame in
position
than seen on . Always check flame prior to each use.
• Inspect burner prior to each use. If burner is damaged
do not use. Call manufacturer at 1-800-232-3398 to
obtain a replacement.
• Turn knob to position. Turn LP cylinder by
turning handwheel clockwise to a full stop.
• Turn gas at LP cylinder. Turn ignitor knob rapidly.
“Click” should be heard and spark seen each time
between burner and electrode. See “Troubleshooting” if
no click or spark.
• Important: Make sure gas is at LP cylinder before
checking valves. Knob locks in position. To check
valve, first push in knob and release, knob should
spring back. If knob does not spring back, replace valve
assembly before using appliance. Turn knob to
position then turn back to
position. Valve should
turn smoothly.
• Before each use, check to see if hose is cut or worn.
Replace damaged hose before using appliance. Use
only hose/valve/regulator specified by manufacturer.
HI
LOW
7
For Safe Use of Your Outdoor Stove Top and to
Avoid Serious Injury:
•
•
•
•
•
•
• Use appliance at least 3 ft.
from any wall or surface.
• Apartment Dwellers:
• NEVER attempt to light burner with lid closed. A
buildup of non-ignited gas inside a closed
appliance is hazardous.
• Never operate appliance with LP cylinder out of
correct position specified in assembly
instructions.
• Always close LP cylinder valve and remove
coupling nut before moving LP cylinder from
specified operation position.
Do not let children operate or play near appliance.
Keep appliance area clear and free from materials that
burn.
Do not block holes in sides or back of appliance.
Check burner flames regularly.
Use appliance only in a well-ventilated space. NEVER
use in enclosed space such as carport, garage, porch,
covered patio, or under an overhead structure of any
kind.
Do not use charcoal or ceramic briquets in a gas
appliance. (
Maintain 10 ft. clearance to
objects that can catch fire or
sources of ignition such as
pilot lights on water heaters,
live electrical appliances, etc..
Check with management to learn the requirements
and fire codes for using an LP gas appliance in your
apartment complex. If allowed, use outside on the
ground floor with a three (3) foot clearance from walls
or rails. Do not use on or under balconies.
Unless briquets are supplied with your
appliance.)