Reznor MAPSIV RECC Parts Manuals - Manual

Form P-MAPS III&IV, PN 262958R5, Page 1
®
®
Form P-MAPS III&IV (12-14)
Obsoletes P-MAPS III&IV (Version A.3)
Applies to: Replacement Parts for Models
RCB, RDB, RDCB, RDDB, RECB, REDB
(MAPS ® III Cabinet Sizes A, B, C, and D)
and Models RCC, RDC, RDCC,
RDDC, RECC, REDC (MAPS ® IV
Cabinet Sizes A, B, and C)
Modular Air Processing Systems,
MAPS ® III & IV, with R-410A Refrigerant
B
Ball Valve 32, 34
Ball Valve Actuator 30, 32, 34
Bearings 17
Belts 12
Blower 16, 29
Exhaust Blower 28
Supply Blower 28
Blower Components 17
Blower Key 17
Blower Sled 17
Burner Assembly 30, 32, 33, 34
Burner Shield 30, 32, 33, 34
Burner Slider 34
Bypass Valve 22
C
Energy Recovery Module Cabinet Parts 28
External Cabinet Parts 38
Venter Motor Capacitor 7
Circuit Board 33
Cirucit Breaker 7
CO2 Sensor 7, 9
Condenser Coil 18, 19, 20, 21, 22, 23
Evaporator Coil 18, 19, 20, 21, 22, 23
Coil Kit 22
Compressor 18, 19, 20, 21, 22, 23
Compressor Mounting Kit 18, 20
Condenser Coil 20, 21
Condenser Fans 18
Condenser Fan System 18, 19, 20, 21, 22
Condenser Sled 24
Contactor 7, 10, 36
Gas Heat Control Board (Varidigm) 7
Ignition Control Board for Gas Heat 8
Control Expansion Board (Option BHB6) 8
Controller Display (BacView) 7
Controller for ER1 Module 28
Convenience Outlet 7, 9
Cooling and Dehumidifying Components 18,
20, 22, 23
Cooling Components for MAPS®III 18,
19, 20
Cooling Components for MAPS®IV 21, 22
Crankcase Heater 18, 19, 20, 21, 22
Cross-Reference by Model/Size and Cabinet
Size 3, 4
D
Damper 27
Damper Linkage 27
Dampers and Controls 27
Date of Manufacture 3
Digital Controller 7, 21, 22
Dirty Filter Sensor 7
Discharge Air Sensor 7, 9
Disconnect Switch (Option CP) 9
Hand Held Display for Digital Controller
(Option RB4) 7
Remote Display for Digital Controller (Option
RB3) 7
Display for Digital Controller 9
Distribution Block 7
Door Assembly 38, 39
Door Hinge/Handle 39
Drain Pan Assembly 38, 40
Drive Components 12, 14
Drive Reactor 10
Drive Table 12
DSI Board 7, 8
Duct Furnace 33
Ductstat 7, 9
E
Parts by Electric Heat Module 36
Electrical Compartment 5
Electrical Compartment and Control
Components 6
Electrical Components - High Voltage
Panel 7
Electric Heat Modules 36
Element 36
Energy Recovery Module 29
Energy Recovery Module, Option ER1A,
ER1B, or ER1C 28
Energy Recovery Wheel 28
Expansion Board (BHB6) 7
F
Plenum Fan 16
Fan Blade 24
Fan Guard 24
Dirty Filter Switch 28
Filter Drier 18, 19, 20, 21, 22, 23
Filters for Energy Recovery Module 28
Inlet Air Filters 25
Firestat 7, 9
Flame Sensor 30, 32, 33, 34
Flue Collection Box 30, 32, 34
Frame Size 10
Frostat 18, 28
Fuse 7, 36
G
Gas Heat Components - Cabinet C 32
Gas Heat Components - Cabinet D 34, 35
Gas Heat Components - Cabinets A and
B 30
Gas Valve 30, 32, 33, 34
H
Hail Guard, Option AZ11 24, 38
Heat Exchanger Assy 30, 33
Heat Exchanger Module 32, 34
Hinge 38, 39
Outside Air Hood 25, 26
Hood Assembly 29
Hot Gas Bypass Valve 22
Humidity Sensor 7, 9, 28
I
ID Plug 8
Ignition Board 32, 34
Ignitor 30, 32, 33, 34
IQ Digital Controller 7, 8
J
JHUP In-Curb Duct Furnaces 33
L
Latch Assembly 38, 39
ECO Limit Device 7
High Temperature Limit 30, 32, 34
Limit Control 33, 36
Linked Belt 13, 15
Locations of Components - Cabinet D 6
Lon Card, Option BHC5 28
M
Manifold Assembly Components 32
Damper Motor 27
Motor 10, 24
Motor Base 16
Motor Mounting 16
Motor Options 10
O
Orifice 30, 32, 33
Manual Overload 36
P
Molded Plug 18, 19, 20, 21, 22
Plug-in Card 7, 8
Power Exhaust 29
Power Supply 7, 8
High Gas Pressure Switch 30, 32
High Refrigerant Pressure Switch 18
Low Gas Pressure Switch 30, 32
Low Refrigerant Pressure Switch 18
Pressure Switch 28, 33
Blower Pulley 12
Motor Pulley 12
R
Rack Assembly (Electric Heat) 36
Rating Plate 2
Reheat Board 7, 8
PAM Relay 7
Relay 7, 33
Reverse Flow Limit 32
Roof Curbs 37
S
Sensors for Monitoring and Reporting to the
Digital Controller 7
Sequencer 7, 8
Serial No. 2
Shaft 17
Smoke Detector 7
Solenoid Kit 20, 21
Starter (AN10) 10
Starter Overload 10
Static Pressure Tap 30, 34
Static Pressure Transducer 9
Air Proving Switch 7, 8
Combustion Air Proving Switch 7, 8
Dirty Filter Pressure Switch 7, 9
Disconnect Switch 7, 9
Gas Manifold Pressure Switch 34
High Gas Pressure Switch 34
High Pressure Switch 20
Low Gas Pressure Switch 34
T
Temperature Sensor 7, 9, 28
Terminal Board 36
Thermister 20, 21, 22
Thermostatic Expansion Valve 18, 20, 21,
22, 23
Time Delay Relay 7, 9
Transducer 7, 28, 30, 32
Transformer 7, 28, 33
V
Variable Frequency Drive (Option VFD) 10
Vent Cover Assembly 40
Venter Housing 30, 32, 33, 34
Venter Motor & Wheel Assembly 30, 32,
33, 34
VFD 10
W
Wiring Harness 28
IMPORTANT
1. Always include complete heater model and serial number
so that any specification change can be considered for
parts replacement. It can save time and expense.
2. Specifications are subject to change without notice.
3. We reserve the right to substitute functional replacements.
4. Order by P/N; not Heater Option Designation.
IMPORTANT: Do not release refrigerant to the atmosphere! If required service
procedures include the adding or removing of refrigerant, the service technician
must comply with all federal, state, and local laws. Service procedures should only
be performed by a qualified HVAC technician.
Cabinet Sizes A, B, and C
• Models RCB & RCC -
Cooling only
• Models RDB & RDC -
Cooling with Reheat
• RDCB & RDCC - Cooling
with Gas Heat Section
• RDDB & RDDC - Cooling
with Reheat and Gas Heat
Section
• RECB & RECC - Cooling
with Electric Heat Section
• REDB & REDC - Cooling
with Reheat and Electric
Heat Section
Cabinet Size D
• Model RCB - Cooling only
• Model RDB - Cooling with
Reheat
• Model RDCB - Cooling
with Gas Heat Section
• RDDB - Cooling with
Reheat and Gas Heat
Section
• RECB - Cooling with
Electric Heat Section
• REDB - Cooling with
Reheat and Electric Heat
Section
Index
® ™