TracRac IM TracTonnuea - Manual

TOOLS REQUIRED:
1. 9/16” Ratchet or Wrench
2. Large Flat Screwdriver
3. 1/8” Allen Wrench
13 ___*___ Black Bow
14 1702992 Spring Plunger, 5/8" x 1.94"
15 1703260 Tension Control Bracket
16 1703345 Spring Pin, 1/8" x 5/16"
17 ___*___ Shur-Bond™ VELCRO ® Fasteners
18 1703332 Hitch Pin, 1/16" x 1 5/16"
19 1703643 Set Screw, 1/4” x 3/8”
20 ___*___ Side Rail, Passenger’s Side
21 ___*___ Side Rail, Driver’s Side
22 1114773 Flat Spring, 5/8" x 3 7/8"
23 1703650 Latch Main Frame
24 1702610 Clevis Pin, 3/16" x 1 1/4"
1 ___*___ TracTonneau Replacement Cover
2 ___*___ Black Header
3 ___*___ Header Seal, Notched
4 1115372 Header End Plugs (Set of Two)
5 1702602 Square Nut, 3/8"
6 1115354 Header Insert Safety Clip
7 ___*___ Safety Strap
8 1114872 Header Guide
9 1703000 Cap Screw, 3/8" x 1 1/2"
10 1115353 Header Safety Strap
11 1703344 Blind Rivet, 1/8" x 3/16"
12 1701595 End Plug, 1" OD
25 1703639 Toggle
26 1700419 Nylon Lock Nut, 5/16"
27 1703265 Toggle Cap
28 1702611 Cotter Pin, 3/64" x 19/32"
29 1702926 Cap Screw, 5/16" x 7/8"
30 1702801 Header Stop
31 1703301 Side Rail End Plug, Left
32 1116263 Side Rail End Seal, 3”
33 1703300 Side Rail End Plug, Right
34 1116265 Side Rail Cab Seal, 4 1/2”
35 1116264 Side Rail Top Gap Seal, 2 5/8”
* Please specify length or make and model of vehicle.
TRACRAC REPLACEMENT PARTS
3 33 3 3”
1
2 3
6
5
4
8
9
11
10
7
2
13
19
18
17
33
14
15
16
20
21
3
31
30
29
23
22 28
25
27
24
26
12
P/N 1116240 Rev A
34
32
35
Thanks for purchasing a TracRac, Inc. product. We proudly make our products in the USA — and we stand behind them. We thoroughly inspect every
product before shipment, and warrant them to the original purchaser to be free from defects in materials and workmanship for a period of 24 months
from the date of purchase.
In the unlikely event that trouble develops during the warranty period, please: Contact TracRac for a return authorization number and instructions
If our inspection shows defective materials or workmanship, we will repair or replace the product (at our discretion) at no charge. We will return the
product to you at our expense.
Proof of purchase is required.
Certain restrictions apply:
This warranty does not apply to normal wear and tear.
Any damage caused by careless, unsafe, excessive use, improper handling, improper installation or alteration are not covered. Overloading beyond
rated capacity, accidents, or repairs attempted by anyone other than TracRac personnel or our Authorized Dealers are not covered.
This warranty applies in lieu of any other warranties, expressed or implied (including implied warranties of merchantability and fitness for a particular
purpose). Variations of its terms are not authorized.
The foregoing obligation is TracRac’s sole liability under this or any other implied warranty, and under no circumstances shall TracRac be liable for
any special, indirect, incidental or consequential damage, whether arising out of breach of warranty, breach of contract or otherwise.
Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitations of incidental or consequential damages, so the above
limitation or exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which vary from state to state.
Purchased from:
Model (SKU) #:
Date of purchase:
This warranty is valid only in the United States of America
To activate your warranty — and to take advantage of our special promotions, new product releases, & product upgrades — please complete the
attached Customer Satisfaction Survey and submit it immediately to TracRac Inc.
Remember: Your Warranty is not in effect unless we receive your completed card within 10 days from your date of purchase. Thanks!
TracRac, Inc. Limited WARRANTY:
994 Jefferson Street, F all River , MA 02721
Phone: 1-508-677-4130 F ax: (508) 677-4136
Customer Service: 1-800-501-1587
Web Site : http://www.tr acrac.com
TracTonneau_IM-F1-A01
10/4/05, 200