Fire Magic Tubular Burners Addendum - Manual

REV 0 - 1504231350 L-C2-422 1
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
Your grill is equipped with tubular (main) burners. Refer to this
addendum for information regarding tubular burner removal,
orifi ce change, air shutter adjustment, and specifi cations.
The following sections replace the equivalent burner
information that is found in the main instructions
supplied with your grill. Read ALL instructions
completely prior to performing any service.
CHANGING THE MAIN BURNER ORIFICE
1. Ensure the grill is completely cool, the knobs are
in the off position, the gas supply to your grill is
turned off, and the power supply is disconnected
(if applicable).
2. Remove the cooking grid and fl avor grid from above
the burner you are working and set them aside.
3. Locate the burner. Slightly pinch and remove the burner
clip (located over the rear center of the burner) from
the burner support and set aside.
4. Carefully lift the burner from the burner support and
out from the hole in the forward fi re wall (see Fig. 1-1 ).
5. Use a 3 /
8
" hex nut driver to remove the exposed orifi ce
(Fig. 1-2). Check orifi ce. If needed, replace it with the
correct orifi ce for the new gas.
6. Replace the burner by fi rst sliding the open cylindrical
end of the burner around the orifi ce, enveloping it and
centering on it, then lower the back end anchor pegs
into the anchor peg holes.
Note: It is critical to the continued safe functioning of the
burner that the orifi ce is centered and completely
inside the burner gas inlet.
7. Re-install the burner clip around the burner and into
the holes in the burner support.
8. Replace the fl avor grid and then the cooking grid so
that the cut-out section is in front.
9. Repeat these steps for each main burner.
Natural-gas to propane-gas conversions using a tank
internal to a portable grill require installation of a propane
tank holder (not included). This tank holder must be
purchased separately from the manufacturer.
INSTALLER: Leave these instructions with consumer.
CONSUMER: Retain for future reference.
Grills Equipped with
Tubular Burners
Addendum
Grill
Model
Burner
Model #
Orifi ce Size
Nat. L.P.
A430 3042-60 #42 #54
A530 3041-60 #40 #53
A540 3042-60 #44 #55
A/E660 3041-60 #42 #54
A/E790 3041-60 #38 #53
A830 3042-60 #42 #54
E1060 3041-60 #40 #53
Fig. 1-1 Remove burner
Fig. 1-2 Remove / replace orifi ce
Orifi ce
Table 1 Specifi cations Table