Polaris 2014 ATV Phoenix 200 - Manual (Page 59)

55
MAINTENANCE
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
D
E
Choke cable 50 H 6 M 500 (800) Inspect; adjust; lubricate;
replace if necessary
E Carburetor air
intake ducts/flange
50 H 6 M 500 (800 Inspect duct for proper seal-
ing/air leaks
Drive belt 50 H 6 M 500 (800) Inspect; adjust; replace as
needed
Ź Engine oil change
100 H 6 M 1000 (1600) Perform a break-in oil change
at 20 hours
Ź Oil filter change 100 H 6 M 1000 (1600) Replace with oil change
Ź Front gearcase oil
(if equipped)
100 H 12 M 1000 (1600) Change fluid
Ź Transmission oil
100 H 12 M 1000 (1600) Change fluid
D
E
Valve clearance 100 H 12 M 1000 (1600) Inspect; adjust
D
E
Fuel system/filter 100 H 12 M 1000 (1600) Check for leaks at tank cap,
lines, fuel valve, filter, pump,
carburetor; replace lines
every two years
Ź Engine mounts
100 H 12 M 1000 (1600) Inspect
Exhaust muffler/
pipe 100 H 12 M 1000 (1600) Inspect
D
E
Spark plug 100 H 12 M 1000 (1600) Inspect; replace as needed
D
E
Ignition Timing 100 H 12 M 1000 (1600) Inspect
Ź Wiring 100 H 12 M 1000 (1600) Inspect for wear, routing,
security; apply dielectric
grease to connectors
subjected to water, mud, etc.
D Clutches (drive
and driven)
100 H 12 M 1000 (1600) Inspect; clean; replace worn
parts
D Front wheel
bearings
100 H 12 M 1000 (1600) Inspect; replace as needed
D Brake fluid 200 H 24 M 2000 (3200) Change every two years
Spark arrester 300 H 36 M 3000 (4800) Clean out
Idle speed - Adjust as needed
D Toe adjustment - Inspect periodically; adjust
when parts are replaced
Headlight aim - Adjust as needed