ShoreLand'r PWC1512 V.1 - Manual

PWC1510, PWC1512 & PWC1513 Parts Manual
PWC1510 PWC 1500# Trailer; White
2 4300181 20.5 X 8 X 10-D Tire/MSilver Mod Rim
1 62340 Literature Bag - Trailers
1 6726801 Frame Bundle - PWC 1510/12/13 - White Tire Size &
Carrying Capacity Chart
Tire Load Carrying
Size Range Capacity
5.30 X 12 C 1045 lbs. p/tire
ST155/80R13 C 1100 lbs. p/tire
Refer to tire side wall for correct tire pressure.
Tongue Weight Adjustment
Approximate Tongue Weight for Best Towing.
Tongue weight too high, move the axle assembly forward. Tongue
weight too low, move the axle assembly backward. Tongue weight
should be 5% to 7% of the total gross weight of the boat and trailer
combined.
Final Assembly Instructions for the PWC1510/1512/1513
Remove the small parts from the frame by cutting the bands.
Remove the bolt bag and sort all the nuts and bolts by size.
Winch Tube Assemblies:
Mount the winch tube assemblies to the frame with 3/8” X 5-7/8”
u-bolts, winch tube straps and 3/8” flange lock nuts.
Axle:
Place one of the spring bushings into the rear of the spring bracket
and secure with a 9/16” X 3-1/4” hex bolt and 9/16” hex lock nut.
Repeat on the other side. Position the axle under the frame, then
hook the spring loop around the bushing just installed. Raise the
axle assembly up so the front of the springs line up with the front
spring bracket hole. Insert the other two (2) 9/16” X 3-1/4” hex bolts
and 9/16” hex lock nuts. Tighten all nuts and bolts, but do not over
tighten. All ow the spring room enough to move.
Mount the tire and rim assemblies with 1/2” lug nuts and tighten to
80-90 ft./lbs. of torque.
Bunks:
Mount the bunk assemblies to the frame with 3/8” X 1” hex bolts in a
location that best fits your watercraft. Secure with 3/8” flange lock
nuts. DO NOT COMPLETELY TIGHTEN FASTENERS. Bunks must
®
PWCG1510 PWC 1500# Trailer; Galvanized
2 4300203 20.5 X 8 X 10-DTire/Galvanized Mod Rim
1 62340 Literature Bag - Trailers
1 6726800 Frame Bundle - PWC 1510/12/13 - Galv.
PWCBK1510 PWC 1500# Trailer; Black
2 4300181 20.5 X 8 X 10-D Tire/MSilver Mod Rim
1 62340 Literature Bag - Trailers
1 6726803 Frame Bundle - PWC 1510/12/13 - Black
PWC1513 PWC 1500# Trailer; White
2 4300210 ST155/80R13C Tire/MSilver Dir Rim
1 62340 Literature Bag - Trailers
1 6726801 Frame Bundle - PWC 1510/12/13 - White
PWCG1513 PWC 1500# Trailer; Galvanized
2 4300209 ST155/80R13C Tire/Galvanized Dir Rim
1 62340 Literature Bag - Trailers
1 6726800 Frame Bundle - PWC 1510/12/13 - Galv.
PWCBK1513 PWC 1500# Trailer; Black
2 4300210 ST155/80R13C Tire/MSilver Dir Rim
1 62340 Literature Bag - Trailers
1 6726803 Frame Bundle - PWC 1510/12/13 - Black
pivot. Leaving the fasteners loose will aid in adjusting your
watercraft to this PWC trailer.
Safety Chain:
Place the two safety chains at the lower front hole on the tongue-
one (1) chain per side of tongue. Secure with 3/8” X 1-1/4” hex bolts
and 3/8” flat washers. Tighten using 3/8” flat washers and 3/8” flange
lock nuts. Refer to the parts drawing for placement.
Coupler:
Mount the coupler onto the tongue with one (1) 1/2” X 4” hex bolt
rear hole on coupler. Using two (2) 1/2” X 1” hex bolts in the front
most holes - secure the coupler to the tongue using 1/2” flange lock
nuts.
Assembly should be complete except for tightening some of
the bolts. These bolts were left loose to aid in adjusting the
trailer to the watercraft only. All fasteners must be tightened
before towing.
NOTE: The law requires that the white ground wire on both the
tongue wire harness and the vehicle harness be properly
grounded to the respective trailer and vehicle frames.
NOTE: ShoreLand’r offers their product line in either galvanized or
painted finish. When ordering parts it is important that you specify
the finish or color you have on your product. The five digit number
along with a two digit space _ _, notes the parts which can be
purchased with various finishes. When ordering these items use the
five digit prefix and include the following two digit suffix for proper
finish.
Suffix Finish / Color
00 or G Galvanized
01 Arctic White
03 or BK Black
PWC1512 PWC 1500# Trailer; White
2 4300184 5.30 X 12-C Tire/MSilver Mod Rim
1 62340 Literature Bag - Trailers
1 6726801 Frame Bundle - PWC 1510/12/13 - White
PWCG1512 PWC 1500# Trailer; Galvanized
2 4300206 5.30 X 12-C Tire/Galvanized Mod Rim
1 62340 Literature Bag - Trailers
1 6726800 Frame Bundle - PWC 1510/12/13 - Galv.
PWCBK1512 PWC 1500# Trailer; Black
2 4300184 5.30 X 12-C Tire/MSilver Mod Rim
1 62340 Literature Bag - Trailers
1 6726803 Frame Bundle - PWC 1510/12/13 - Black
Service manual effective for models with
VIN numbers after 206205.