Everpure CB20-312E - Manual (Page 2)

PERFORMANCE DATA
CB20-312E System Replacement Cartridge Kit EV9105-34
1- CC1E Replacement Cartridge (Gray end caps)
2- CC3E Replacement Cartridge (White end caps)
FEATURES
• Finely polishes treated water to premium quality for drinking and
cooking.
• Reduces disinfectant chlorine taste & odor and chloramine taste &
odor.
• Reduces dirt, rust, and other particulates such as oxidized iron,
manganese, and sulfides.
• Reduces parasitic protozoan cysts such as Giardia, Entamoeba,
Cryptosporidium.
• Reduces common earthy, moldy, fishy tastes and odors.
HEALTH CLAIM PERFORMANCE CERTIFIED
BY NSF/ANSI*
This system has been tested according to NSF/ANSI 42 and 53 for
the reduction of the substances listed below. The concentration of the
indicated substances in water entering the system was reduced to a
concentration less than or equal to the permissible limit for water leav-
ing the system, as specified in NSF/ANSI 42 and 53.
Substance Influent Challenge Max. Permissible Product Reduction Minimum Average
Concentration Water Concentration Requirements Reduction Reduction
Aesthetic Effects
Chlorine 2.0 mg/L ± 10% ≥50% 97.5%
Chloramine 3.0 mg/L ± 10% 0.5 mg/L 97.5%
Particulate, Class I
particles
at least 10,000 ≥85% 99.1%
0.5 to < 1µm particles/mL
Health Effects
Cyst† Minimum 50,000/L 99.95% 99.99% 99.99%
Turbidity 11 ± 1 NTU 0.5 NTU 98.9% 99.2%
† Based on the use of microspheres.
* Tested using Flow rate = 5.0 gpm; Pressure = 60 psig; pH = 7.5 ±0.5; Temperature = 20˚C ±3˚C
OPERATING SPECIFICATIONS
Capacity: 60,000 gallons (227,100 L)
Pressure requirement: 20 - 100 psi (1.4 - 6.9 bar), non-shock
Temperature: 35 - 100°F (2-38°C)
Flow Rate: 5 gpm (19 Lpm)
Operating Weight: 90 lbs.
GENERAL INSTALLATION/OPERATION/
MAINTENANCE REQUIREMENTS
• Mount system to wall studs 16" on center (spacing of mounting
plate holes) on other surface capable of supporting 90 pounds
when system is filled with water.
• Connect water supply to inlet of CB20-312E system.
• Connect outlet water to beverage equipment.
• After installing the CC1E cartridge, flush cartridge at full flow for 5
minutes. Install CC3E cartridges and flush system for
10 minutes.
• Replace cartridges when capacity is reached, or when flow
becomes too slow, but at least every 6 months.
SPECIAL NOTICES
• Installation instructions, parts and service availability, and
standard warranty are included with the product when shipped.
Installation by certified installer is recommended.
• This drinking water system must be maintained according to man-
ufacturer’s instructions, including replacement of filter
cartridges.
• Do not use with water that is microbiologically unsafe, or of
unknown quality without adequate disinfection before or after the
system. Systems certified for cyst reduction may be used on dis-
infected waters that may contain filterable cysts.
• The contaminants or other substances removed or reduced by
this water treatment system are not necessarily in your water.
• Check for compliance with state and local laws and
regulations.
• Testing was performed under standard laboratory conditions;
actual performance may vary.
©2005 by Everpure, LLC MR/05 146527 Rev A
EVERPURE, LLC
1040 Muirfield Drive
Hanover Park, IL 60133
TEL 800-323-7873
Customer Service
FAX 800-942-0081
Visit us online at: www.everpure.com
In Europe:
EVERPURE EUROPE NV
Toekomstlaan 30
B-2200 Herentals
Belgium
Tel 32 14 28 35 00
FAX 32 14 28 35 05 In Japan:
EVERPURE JAPAN, INC.
1-8-19, Tsumada Kita,
Atsugi-Shi
Kanagawa 243
Japan
Tel 81-462 (23) 6563
FAX 81-462 (21) 6775