Sealey SA6004 User Manual
Sa6004, Instructions for, Model no
InstructIons For:
AIR IMPACT WRENCH 3/4" SQ DRIVE
COMPACT TWIN HAMMER
model no:
SA6004
1. SAfETy
3. SPECIfICATION
2. INTRODuCTION
sA6004 Issue: 1 - 11/11/14
Original Language Version
© Jack sealey limited
IMPORTANT: PLEASE READ THESE INSTRuCTIONS CAREfuLLy. NOTE THE SAfE OPERATIONAL REQuIREMENTS, WARNINGS & CAuTIONS. uSE THE PRODuCT
CORRECTLy AND WITH CARE fOR THE PuRPOSE fOR WHICH IT IS INTENDED. fAILuRE TO DO SO MAy CAuSE DAMAGE AND/OR PERSONAL INJuRy AND WILL
INVALIDATE THE WARRANTy. KEEP THESE INSTRuCTIONS SAfE fOR fuTuRE uSE.
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
WARNING! DO NOT use wrench if damaged or thought to be faulty. contact service Agent.
WARNING! disconnect from the air supply before changing accessories or servicing.
WARNING! due to the possible presence of asbestos dust from brake linings, when working around vehicle brake systems we recommend
you wear suitable respiratory protection.
WARNING! check correct air pressure is maintained and not exceeded. We recommend 90psi.
DO NOT use the wrench for a task it is not designed to perform.
DO NOT use worn, or damaged sockets
DO NOT use the wrench unless you have been instructed in its use by a qualified person.
DO NOT use the wrench for a task it is not designed to perform.
DO NOT carry the wrench by the air hose.
DO NOT operate the wrench if you are tired or under the influence of alcohol, drugs or intoxicating medication.
DO NOT carry the wrench with your hand on the power trigger in order to avoid unintentional starting.
DO NOT direct air from the air hose at yourself or others.
maintain the
wrench in good condition and replace any damaged or worn parts. Use genuine parts only. Unauthorised parts
may be dangerous and will invalidate the warranty.
Keep air hose away from heat, oil and sharp edges. check air hose for wear before each use and ensure that all connections are
secure.
only use impact sockets which are specifically designed for use with an impact wrench.
Wear approved safety eye/face shield, ear defenders, dust mask and hand protection.
Follow all workshop safety rules, regulations, and conditions when using the wrench.
maintain correct balance and footing. ensure the floor is not slippery and wear non-slip shoes.
operate with both hands when practical to do so.
Keep children and non essential persons away from the working area.
When not in use disconnect from air supply and store in a safe, dry, childproof location.
WARNING! The warnings, cautions and instructions in this manual cannot cover all possible conditions and situations that
may occur. It must be understood by the operator that common sense and caution are factors which cannot be built into
this product, but must be applied by the operator.
compact and lightweight compared to traditional 3/4" impact
wrenches, yet still produces a high torque output. composite
casing with two extruding edge strips to help protect housing.
specially designed motor gives high torques whilst working on low
air consumption. one hand operation with three speed selector
switch and forward/reverse control at your fingertips. Handle
features a downward facing exhaust to lower noise level and soft
grips to help reduce vibration and chill. suitable for professional
garage use.
Model No: . . . . . . . . . . . . . . . . . . . . . . SA6004
drive: . . . . . . . . . . . . . . . . . . . . . . . . . . . 3/4"sq
Working torque: . . . . . . . . . . . 800lb.ft/1085nm
maximum torque:. . . . . . . . . . 900lb.ft/1220nm
ultimate torque: . . . . . . . . . . 1100lb.ft/1492nm
Free speed: . . . . . . . . . . . . . . . . . . . . 5000rpm
Air consumption: . . . . . . . . . . . . . . . . . . 4.9cfm
operating Pressure: . . . . . . . . . . . . . . . . . 90psi
Air Inlet size: . . . . . . . . . . . . . . . . . . . 1/4“ BsP
Weight: . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.6kg
noise Power: . . . . . . . . . . . . . . . . . . . 111.6dBA
noise Pressure: . . . . . . . . . . . . . . . . .100.6dBA
refer to instruction
manual
Wear ear protection Wear eye protection
Wear protective
gloves
Wear a dust mask