Subaru Robin PKV110 - Manual (Page 7)

US
G B
G B
G B
G B
G B
When warranty repair is needed, the engine must be brought to an
authorized service dealer or warranty station’s place of business during
normal business hours. In all cases, a reasonable time, not to exceed
30 days, must be allowed for the warranty repair to be completed after
the engine is received by the authorized service dealer or warranty station.
G . MA INT E NA NC E , R E P L A C E ME NT A ND
R E P A IR OF E MIS S ION-R E L A T E D P A R T S
Only warranted engine replacement parts approved by F UJ I should
be used in the performance of any warranty maintenance or repairs
on emission-related parts. If other than authorized parts are used for
maintenance, replacement or repair of components affecting emission
control, you should assure yourself that such parts are warranted by
their manufacturer to be equivalent to authorized parts in performance
and durability. F UJ I ,however, assumes no liability under this warranty
with respect to parts other than authorized parts. T he use of non-
authorized replacement parts does not invalidate the warranty on
other components unless the non-authorized parts cause damage to
warranted parts.
H. P AR TS C OVE R E D UNDE R THE C AL IF OR NIA E MIS S IONS
WAR R ANTY
(1) F uel Metering S ystem
(i) C arburetor and internal parts
(ii) Air cleaner plate (including choke system)
(iii) Air cleaner cover
(iv) Air cleaner element
(2) Ignition S ystem
(i) S park plug
(ii) F lywheel magneto
(iii) Ignition coil
(3) Miscellaneous Items Used in Above S ystems
(i) Hoses and sealing gaskets, bolts, connectors, and assemblies.
I. MA INT E NA NC E S T A T E ME NT S
It is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2000 and later
Owner's Manual and to retain proof that inspection and maintenance services are performed at the times when recommended. F UJ I will not
deny a warranty claim solely because you have no record of maintenance; however, F UJ I may deny a warranty claim if your failure to perform
required maintenance resulted in the failure of warranted part. T he proof which you maintain should be given to each subsequent owner of the
engine. Y ou are responsible for performing the scheduled maintenance described below based on the procedures specified in the 2004 and
later Owner's Manual. T he scheduled maintenance below is based on a normal engine operating schedule.
P R OC E DUR E INT E R V AL
1) C lean engine and check bolts and nuts. R etighten if necessary. : E very 8 hours (daily)
2) C heck and refill engine oil (4 stroke) : E very 8 hours (refill daily up to upper limit)
3) C hange engine oil (4 stroke) : Initial 20 hours and every 100 hours afterward
4) C heck clogging of cooling air passage and cylinder fins. : E very 8 hours (daily)
Note: More frequent maintenance may be necessary under dusty, dirty or severe conditions.
(v) F uel F ilter
R emove and clean if necessary.
12) R eplace packings and gaskets with new ones.
11) Overhaul engine.
10) R eplace fule lines.
9) Adjust valve clearance, if applicable (4 stroke)
8) C heck fuel filter. If clogged, replace with new one.
7) C heck muffler exhaust outlet (or port). C lean if necessary.
6) C heck spark plug. C lean and adjust if necessary.
5) C lean air cleaner
: E very reassembling
: E very 200 hours
: E very 8 hours (daily)
: E very 8 hours (daily)
: E very 50 hours (monthly)
: E very 50 hours (monthly)
: E very 200 hours
: E very 200 hours