Earlex ASG55 - Manual (Page 2)

● Keep work area clean - Cluttered areas and benches
invite injuries.
● Consider work area environment - Do not expose the
spray gun to rain. Do not use the spray gun in damp
or wet locations. Keep work area well lit.
● Guard against electric shock - Avoid body contact with
earthed or grounded surfaces (e.g. pipes, radiators,
ranges, refrigerators).
● Keep children away from the spray gun.
● When not in use, paint sprayer should be stored in a
dry, high or locked place, out of reach of children.
● Use the paint sprayer for the job it was designed for
only. Mis-use of the spray gun will invalidate the
guarantee.
● Dress properly - do not wear loose clothing or
jewellery, they can be caught in moving parts. Rubber
gloves and non-skid footwear are recommended when
working outdoors. Wear protective hair covering to
contain long hair.
● Always wear a mask when spraying.
● We recommend the use of eye protection to keep
hazardous vapours out of eyes.
● We recommend the use of ear protectors.
● Do not abuse the cord - Never carry the tool by the
cord or pull it to disconnect it from the socket. Keep
the cord away from heat, oil and sharp edges.
● Do not overreach - Keep proper footing and balance
at all times.
● Always disconnect from mains supply when not in
use, when refilling the paint container and before
cleaning.
● Avoid unintentional starting, do not carry a plugged in
tool with a finger on the switch.
● When tool is used outdoors, use extension cords only
intended for outdoor use.
● It is recommended that a RCD (residual current
device) rated at 30mA is fitted into the mains supply
socket for added protection against electric shock.
● Stay alert - Watch what you are doing. Use common
sense and do not operate tool when you are tired.
● Never under any circumstances aim the nozzle at
another person or animal. In the event of injury
occuring seek expert medical advice immediately.
● Always keep the spray nozzle in place during
use. Never allow the spray nozzle to come in direct
contact with the skin.
● Always ensure there is adequate ventilation when
spraying.
● Never spray near a source of ignition, e.g. hot
surfaces, sparks, cigarettes, glowing wires & open
flames including appliance pilot flame.
● The paint sprayer must not be used for spraying
flammable materials having a flash point below 21˚C.
● Always beware of any hazards presented by the
material being sprayed and consult the markings on
the container or the information supplied by the
manufacturer of the material to be sprayed, including
requirements for the use of personal protective
equipment. Do not spray any material where the
hazard is not known.
● The paint sprayer must not be cleaned with flammable
liquids having a flash point below 21˚C.
● Check for damaged parts - Before further use of the
paint sprayer, a guard or other part that is damaged
should be carefully checked to determine that it will
operate properly and perform its intended function.
Check for alignment of moving parts, free running of
moving parts, breakage of parts, mounting and any
other conditions that may affect its operation. A guard
or other part that is damaged should be properly
repaired or replaced by an authorized service centre
unless otherwise indicated in this instruction manual.
Have defective switches replaced by an authorized
service facility. Do not use the tool if the switch does
not turn it on and off.
● Warning - The use of any accessory or attachment,
other than those recommended in this instruction
manual, may present a risk of personal injury.
● Maintain tools with care - Follow instructions for
lubrication and changing the accessories, inspect tool
regularly and if damaged, get repaired by an
authorized service centre.
● Have your tool repaired by a qualified person – This
electric tool is in accordance with the relevant safety
requirements. Repairs should only be carried out by
qualified persons using original spare parts, otherwise
this may result in considerable danger to the user.
● Do not spray any material where the hazard is
not known.
● Use genuine Earlex parts only.
● This appliance is not intended for use by persons
(including children) with reduced physical, sensory or
mental capabilities, or lack of experience and
knowledge, unless they have been given supervision or
instruction concerning use of the appliance by a person
responsible for their safety.
WARNING: When using the Paint Sprayer, basic safety precautions, including the
following, should always be followed to reduce the risk of fire, electric shock and
personal injury.
NOISE AND VIBRATION LEVELS
The following values were measured in accordance with EN50144-2-7
A-weighted sound power level: 99.9dB(A)
Vibration level: 8.824 m/s 2
2
SAFETY OPERATING INSTRUCTIONS