Generac 004700-0 - Manual (Page 6)

4 Generac ® Power Systems, Inc.
1. Generator Air Intake
2. Engine Start/Stop Switch
3. Fuse
4. Optional Remote Panel Receptacle
(Side View)
5. Generator AC Output Leads (Side
View)
6. Fuel Primer Switch
7. Circuit Breaker
8. Starter Contactor
9. Fuel Inlet
10. Fuel Pump (Behind Access Panel)
11. Fuel Filter (Side View)
12. Oil Filter
13. Oil Drain Cap
14. Oil Dipstick
15. Air Filter (Behind Access Panel)
16. Oil Fill
17. Spark Plug
Section 1 – General Information
QUIETPACT 40G Recreational Vehicle Generator
Please record the following information from the generator DATA DECAL or information decal.
1. Model Number ____________________ 2. Serial Number __________________
3. kW Rating__________________________ 4. Rated Voltage __________________
RAC OHVI INDUSTRIAL ENGINE
I t r e , e w a
D
W
AC
TM
RV SERVICE LOCATOR: 1.800.333.1322
PACT 40G
*
S E R V IC E A C C E S S P A N E L
OIL LEVEL: CHECK DAILY
AIR FILTER: CLEAN PREFILTER
EVERY 100 HOURS.
REPLACE ELEMENT
EVERY 250 HOURS.
OIL & OIL FILTER: CHANGE EVERY 100
(IF NECESSARY) EVERY 500 HOURS. HOURS. REPLACE PLUGS PLUGS EVERY 100 INSPECT & CLEAN SPARK PLUGS:
REPLACEMENT INFORMATION
*
PERFORM MORE OFTEN IN DUSTY CONDITIONS
AIR FILTER LOCATED BEHIND PANEL.
MAINTENANCE SCHEDULE
AIR FILTER P/N: 0D3262 070185 OIL FILTER P/N: SPARK PLUG P/N: 072347
OIL CAPACITY WITH FILTER: 0.8L/0.84QT TEMPERATURE SAE VISCOSITY
32˚F AND HIGHER 10˚F TO 100˚F 0˚F TO 80˚F -20˚F TO 50˚F 5W-30 10W-30 15W-40 30
WHEN SERVICE OR PARTS ARE NEEDED IN THE USA OR CANADA, CONTACT THE GENERAC SERVICE LOCATOR AT 1-800-333-1322.
HOURS. (OR ANNUALLY)
PREFILTER P/N: 0D4511
FUEL FILTER P/N: 0D7515
FUEL FILTER: CHANGE EVERY 400
HOURS. (OR ANNUALLY)
* *
P R I M E
F U E L
S T O P
S T A R T 3 0 A C . B .
1 5 A F U S E
CONTROL CENTER
1
2
3
7
6
10/15
17 8 14,16
13 12
4
5
9/11
1.1 GENERATOR IDENTIFICATION
Model: 004700-0 — QUIETPACT 40G