Little Wonder Tiller/Cultivator - Manual (Page 23)

23
TROUBLE SHOOTING
1. Tines don’t turn when throttle
is depressed
Engine is not seated properly on
the gear housing.
Re-install engine following the
instructions on page 20 (How to
re-seat the flange).
2. Engine fails to start Start/Stop switch is in Stop
position.
No fuel in tank.
Fuel strainer clogged.
Fuel line clogged.
Spark plug shorted or fouled.
Spark plug is broken (cracked
porcelain or electrodes broken)
Ignition lead wire shorted,
broken or disconnected from
spark plug.
Ignition inoperative
Move switch to start.
Fill Tank.
Replace Strainer.
Clean fuel line.
Install new spark plug.
Replace spark plug.
Replace lead wire or attach to
spark plug.
Contact your local authorized
dealer.
3. Engine hard to start. Water in gasoline or stale fuel
mixture.
Too much oil in fuel mixture.
Engine under or over choked.
Carburetor out of adjustment.
Gasket leaks (carburetor or
cylinder base gasket).
Weak spark at spark plug.
Drain entire system and refill
with fresh fuel.
Drain and refill with correct
mixture.
If flooded by over choking,
proceed according to
instructions in operation
section. If under choked, move
choke lever to closed position
and crank two or three times.
See “Carburetor Adjustment”
Replace gaskets.
Contact your local authorized
dealer.
4. Engine misses. Dirt in fuel line or carburetor.
Carburetor improperly adjusted.
Spark plug fouled, broken or
incorrect gap setting.
Weak or intermittent spark at
spark plug.
Remove and clean.
See “Carburetor Adjustment”.
Clean or replace spark plug - set
gap to .024-.028 in. (0.6-0.7 mm )
Contact your local authorized
dealer.
Problem Cause Remedy